|
Gas Yamaha Gas Yamaha Golf Cars; G1 through "The Drive" and U-Max Utility Vehicles |
|
Thread Tools | Display Modes |
05-08-2017, 05:17 AM | #1 |
Not Yet Wild
Join Date: Jul 2012
Posts: 10
|
2002 Yamaha G16 Gas Wont start
i have a G16 that wont start it would run and shut off while driving than start back up, i got a new carburetor for it and installed it now wont run at all i get it to fire and low idle some of the times it acts like theres no fuel the plug is dry i pulled the fuel pump from another cart that runs and no change it does back fire threw the carb when i try to start it at full throttle sometimes but not all the time, at my wits end here i pulled in shop put the jakes clutch kit in and changed carb hasnt moved since.
|
Today | |
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
05-08-2017, 06:53 AM | #2 |
Gone Wild
Join Date: Jun 2011
Location: Northern Indiana
Posts: 2,823
|
Re: 2002 Yamaha G16 Gas Wont start
Carburetor. If you follow some of the threads here you'll find a common rant. The $80+ part from a "reputable vendor " may well be the same$19 one off Amazon- made in China with no quality control. Could go through 4 or 5 before you find one that works even just ok. Rebuilding the original (if you still have it) is the way to go.
|
05-08-2017, 10:28 AM | #3 |
Not Yet Wild
Join Date: Jul 2012
Posts: 10
|
Re: 2002 Yamaha G16 Gas Wont start
I tried 18.00 carb than got 56.00 carb at dealer same result
|
05-08-2017, 11:00 AM | #4 |
Gone Wild
Join Date: Jun 2015
Location: NW Iowa
Posts: 1,669
|
Re: 2002 Yamaha G16 Gas Wont start
Check valve lash then check compression will it fire if you spray a little carb cleaner or ether in it?
|
05-08-2017, 12:36 PM | #5 |
Not Yet Wild
Join Date: Jul 2012
Posts: 10
|
Re: 2002 Yamaha G16 Gas Wont start
It will fire sometimes not always
|
05-08-2017, 09:34 PM | #6 |
Over This Interview Is...
Join Date: Jun 2012
Location: AZ
Posts: 17,449
|
Re: 2002 Yamaha G16 Gas Wont start
Just in case you were wondering "did I get a real Yamaha carb, or cheap China garbage?"
|
05-09-2017, 05:01 AM | #7 |
Not Yet Wild
Join Date: Jul 2012
Posts: 10
|
Re: 2002 Yamaha G16 Gas Wont start
holy Crap! well u get what u pay for can u send me that link?
|
05-09-2017, 06:13 AM | #8 |
Gone Wild
Join Date: May 2015
Location: Central Florida
Posts: 2,114
|
Re: 2002 Yamaha G16 Gas Wont start
Its rare a carburetor goes bad anyway. Reading through these threads you see hundreds changed, the reality is 95 percent didn't need to be changed.
Same goes with fuel pumps-rare they fail. Simple check-When it doesn't run-spray some carb cleaner into the carb and see if it fires on that, if so, you know its a fuel issue at that point. Most common issue is a clogged carb, but a simple clean, fixes it. Also check fuel lines for a leak as that will cause fuel not to flow. |
05-09-2017, 07:45 AM | #9 | |
Not Yet Wild
Join Date: Jul 2012
Posts: 10
|
Re: 2002 Yamaha G16 Gas Wont start
Quote:
Sent from my XT1585 using Tapatalk |
|
05-09-2017, 09:34 PM | #10 |
Not Yet Wild
Join Date: May 2014
Location: Florida West Coast
Posts: 50
|
Re: 2002 Yamaha G16 Gas Wont start
Three questions:
- Is the fuel in the tank more than 6 months old? - Does the fuel contain Ethanol? - Did you ensure that the fuel supply lever (top of tank on mine) was in the 'on' position? I've committed all three of the above 'stupid sins', and I bet I'm not alone. Good Luck |
|
|
Similar Threads | ||||
Thread | Forum | |||
99 Yamaha G16 wont start | Gas Yamaha | |||
2002 Gas Club Car Turns over wont Start | Gas Club Car | |||
2002 Yamaha G16 Gas Cart won't start after winter | Gas Yamaha | |||
2002 club gas wont start | Gas Club Car |