|
Gas Yamaha Gas Yamaha Golf Cars; G1 through "The Drive" and U-Max Utility Vehicles |
|
Thread Tools | Display Modes |
04-08-2009, 05:14 PM | #1 |
Not Yet Wild
Join Date: Mar 2009
Location: Southwest Virginia
Posts: 11
|
my G1 stoped and wont start
I have had this G1 for a few weeks. I have changed sparkplug,fuel filter and airfilter, this thing runs graet, then today after running around and driving up and down my road, I came to a stop and it would not start up again. I put up on jackstands and cranked motor and starter runs foward and reverse but wont start up, any ideas ? .
|
Today | |
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
04-08-2009, 05:22 PM | #2 |
Admin
Join Date: Dec 2006
Location: TN
Posts: 101,856
|
Re: my G1 stoped and wont start
Check fuel, spark, and air. It may be the solenoids on the back passenger fender. Usually these only go out one at a time though. Make sure the little wire on the coil where the spark plug wire is attached, isn't broken (little orange wire I think).
|
|
|
04-08-2009, 08:00 PM | #3 |
Admin/Moderator
Join Date: Dec 2006
Location: Ohio
Posts: 18,046
|
Re: my G1 stoped and wont start
Check the fuses on the passages side rear inner fender on top.
|
Ron
PLEASE VISIT Our Sponsors * BGW GEAR The Store The G2 Project * Swing Arm Drop & Repair * Geep1 Project |
|
04-10-2009, 04:09 PM | #4 |
Not Yet Wild
Join Date: Mar 2009
Location: Southwest Virginia
Posts: 11
|
Re: my G1 stoped and wont start
Ok, I have checked all the fuses and all connections. Added new spark plug, still not running. All switches, celenoid, and petal switch seems to be working. Definately got a spark!!! (just ask my fingers) Pulled fuel line loose and seems to be getting plenty of fuel. Could carb be gunked up, causing it not to run? I guess next step is cleaning carb??? Does anyone know the acceptable compression for the G1? Have not done the compression check yet. Any help will be great, thanks in advance.
|
04-10-2009, 08:03 PM | #5 |
Admin/Moderator
Join Date: Dec 2006
Location: Ohio
Posts: 18,046
|
Re: my G1 stoped and wont start
Yes, pull the carb off, clean it and make sure the float is working freely. Gumout carb cleaner works well. Is your gas fresh?
|
Ron
PLEASE VISIT Our Sponsors * BGW GEAR The Store The G2 Project * Swing Arm Drop & Repair * Geep1 Project |
|
04-11-2009, 07:04 AM | #6 |
Admin
Join Date: Dec 2006
Location: TN
Posts: 101,856
|
Re: my G1 stoped and wont start
If your getting fuel and spark, check the muffler to see if it is stopped up. You also have an exhaust valve on the front of the engine that works in conjunction with the carb. linkage. Make sure it isn't stuck closed.
|
|
|
04-11-2009, 08:43 AM | #7 | |
Not Yet Wild
Join Date: Mar 2009
Location: Southwest Virginia
Posts: 11
|
Re: my G1 stoped and wont start
Quote:
Thanks in advance for your help. |
|
04-11-2009, 08:45 AM | #8 |
Admin
Join Date: Dec 2006
Location: TN
Posts: 101,856
|
Re: my G1 stoped and wont start
I think around 120 or so.
|
|
|
04-11-2009, 08:46 AM | #9 |
Not Yet Wild
Join Date: Mar 2009
Location: Southwest Virginia
Posts: 11
|
Re: my G1 stoped and wont start
Gee Spriddle thanks for such a quick response. Now I will check that today.
Thanks again!! |
04-11-2009, 10:35 PM | #10 |
Not Yet Wild
Join Date: Apr 2009
Posts: 11
|
Re: my G1 stoped and wont start
Welcome to the club... I have the exact same problem. New gas, spark plug, disassembled, cleaned carb., removed exhaust, checked fuel pump, etc...engine will idle(exhaust gets hot), no power... I suspect float adjustment... Old float needle lost, new one has spring in float end...normal??? Help spriddle
|
|
|
Similar Threads | ||||
Thread | Forum | |||
my g1 wont start on its own | Gas Yamaha | |||
G1 wont start? | Gas Yamaha | |||
wont start. | Gas Yamaha | |||
82 h. d. wont start help | Gas Harley Davidson | |||
wont start | Gas Club Car |