|
Gas Yamaha Gas Yamaha Golf Cars; G1 through "The Drive" and U-Max Utility Vehicles |
|
Thread Tools | Display Modes |
04-05-2011, 02:13 PM | #1 |
Not Yet Wild
Join Date: Apr 2011
Location: Knoxville TN
Posts: 4
|
Governor mod / Throttle response
First of all I just purchased my first cart last Thurs 4/1/10.(Total stock '04 G22) and of course the first thing I wanted to do was make it faster. Found this forum and on Fri did the modification suggested by Cart de golf....What a difference and very simple..Ok so after riding the cart some I have noticed your ether wide open or no throttle at all.. No just cursing around mid throttle. If I try mid throttle it gets real jerky.
Have done the full tune up as well- Air filter, spark plug, New gas, Etc. Any ideas?? |
Today | |
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
04-05-2011, 03:56 PM | #2 |
Gone Wild
Join Date: Mar 2010
Location: Eminence, IN
Posts: 534
|
Re: Governor mod / Throttle response
sounds like you have the butterfly adjusted wrong. If you get it adjusted right then you will probly loose JUST A LITTLE top end but you gain the ability to cruise at any speed.
|
04-05-2011, 04:11 PM | #3 |
Not Yet Wild
Join Date: Apr 2011
Location: Knoxville TN
Posts: 4
|
Re: Governor mod / Throttle response
Thanks for your reply...but being totally new to carts, Could you expand a bit. How do I adjust the butterfly? And what is the correct adjustment.
Thanks again |
04-05-2011, 04:35 PM | #4 |
G8 Club Founding Member
Join Date: Sep 2010
Location: Middle of Virginia, USA
Posts: 4,265
|
Re: Governor mod / Throttle response
I did the same thing as you. Brought the throttle cable directly to the carb. Got the same response from the motor - All or nothing! You need to back the cable end (attached to the carb) back - or towards the rear of the cart. Its exactly opposite of what you'd think it needs. Just loosen the two 10mm nuts which hold the cable in place and move those nuts back towards the back of the cart. This gives the butterfly more play.
|
|
|
Similar Threads | ||||
Thread | Forum | |||
Breif moment of No Throttle response | Electric EZGO | |||
Throttle response only 77% CC 48 volt | Electric Club Car | |||
95s throttle response instant any adjustments | Gas Club Car | |||
Throttle Response | Electric EZGO | |||
Throttle response on this '96 TXT is all or none | Electric EZGO |