|
Gas Yamaha Gas Yamaha Golf Cars; G1 through "The Drive" and U-Max Utility Vehicles |
|
Thread Tools | Display Modes |
05-07-2008, 09:28 PM | #1 |
Not Yet Wild
Join Date: May 2008
Posts: 2
|
Gear Problems
I have a 1985 G2A gas Yamaha cart. It runs great. However, when I pull a wagon it grabs a lower gear and pulls hard until you let off the throttle and slow almost to a stop, then it drops out of the lower gear and goes normally unless you give it alot of gas. How can I fix this problem.
|
Today | |
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
05-08-2008, 04:33 PM | #2 |
The Overposter!
Join Date: Nov 2007
Location: Dixie
Posts: 1,586
|
Re: Gear Problems
Have you greased your clutches recently?
|
05-08-2008, 05:34 PM | #3 |
Admin/Moderator
Join Date: Dec 2006
Location: Ohio
Posts: 18,046
|
Re: Gear Problems
Welcome to the forum!!
Yep, sounds like your clutches are not sliding free. There should be a zerk fitting on the front clutch (drive) and on the rear clutch (driven). Give them each 2-3 squirts. If you pump too much you will have other problems. |
Ron
PLEASE VISIT Our Sponsors * BGW GEAR The Store The G2 Project * Swing Arm Drop & Repair * Geep1 Project |
|
05-08-2008, 06:29 PM | #4 |
Not Yet Wild
Join Date: May 2008
Posts: 2
|
Re: Gear Problems
Thanks for the help. What type of grease should I use?
|
05-08-2008, 07:25 PM | #5 |
Admin/Moderator
Join Date: Dec 2006
Location: Ohio
Posts: 18,046
|
Re: Gear Problems
General purpose bearing grease would be good.
|
Ron
PLEASE VISIT Our Sponsors * BGW GEAR The Store The G2 Project * Swing Arm Drop & Repair * Geep1 Project |
|
10-22-2008, 09:14 PM | #6 |
Getting Wild
Join Date: Oct 2008
Location: Heber Springs, ARKANSAS
Posts: 113
|
Re: Gear Problems
Where u from vance 98? I'm also a vance originally from Oxford, Mississippi.
|
10-23-2008, 11:30 AM | #7 |
Golf Cart Photographer
Join Date: Jan 2007
Location: Wichita Falls Texas - My Ride 2010 Club Car
Posts: 6,236
|
Re: Gear Problems
Welcome to the forum vance98.........................
|
Tags |
cart, gas, gears, transmission, yamaha |
|
Thread Tools | |
Display Modes | |
|
Similar Threads | ||||
Thread | Forum | |||
Rear end gear oil | Electric EZGO | |||
Tough to get in gear | Gas Club Car | |||
New Gear Set | Lifted Golf Carts | |||
'96 TXT gear ratio | Big Block Talk! | |||
'96 TXT gear ratio | Gas EZGO |