lifted club cars - lifted ezgo
Home FAQDonate Who's Online
Go Back   Buggies Gone Wild Golf Cart Forum > Golf Cart Repair and Troubleshooting > Gas Yamaha
Gas Yamaha Gas Yamaha Golf Cars; G1 through "The Drive" and U-Max Utility Vehicles



Post New Thread  Reply
Thread Tools Display Modes
Unread 10-18-2011, 01:49 PM   #1
Not Yet Wild
 
Join Date: Sep 2011
Posts: 2
Default g1 not firing

was driving down the road almost full throttle and it shut down on me. looked like no fuel in the filter so got it home pulled fuel line off at carb and fuel came out when i turn it over. I don't have a spark tester at this moment (will pick one up this week) but when i ground it out i get nothing? all wires are plugged in and fuses good that I know of. the mount for the coil is cracked but it's plastic would that affect anything?
taylorj558 is offline   Reply With Quote
Alt Today
BGW

Golf car forum Sponsored Links

__________________
This advertising will not be shown in this way to registered members.
Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum
   
Unread 10-18-2011, 05:38 PM   #2
Gone Wild
 
GMB74's Avatar
Yamaha
 
Join Date: Jun 2009
Location: Heluvabump,VT
Posts: 623
Default Re: g1 not firing

Will it crank and start in reverse?

Take your connections apart and check carefully for corrosion, broken wires and connectors, or loose connections. Very common on these old buggies.

Check out this thread:

g1 ignition questions
GMB74 is offline   Reply With Quote
Unread 10-19-2011, 10:37 AM   #3
Not Yet Wild
 
Join Date: Sep 2011
Posts: 2
Default Re: g1 not firing

It wasn't starting in reverse. I found the issue thanks to your response! you saved me some time on this one . It turned out to be that it was showing with a test light that ground was good on the case of the coil. since the plastic mount was broken, the bolt was loose that held the ground wire onto the side of the coil just enough to get some rust and a little crud in there. after simply cleaning the connections with a wire brush it starts right up!!! Thanks again for the pointers.

Just curious if it was starting in reverse that would have been a timing issue right? when I did crank shaft seals I tried my best to set it to the marks I made where it was before.
taylorj558 is offline   Reply With Quote
Reply

Tags
2 cycle no spark, not firing, yamaha, yamaha g1
Go Back   Buggies Gone Wild Golf Cart Forum > Golf Cart Repair and Troubleshooting > Gas Yamaha


Thread Tools
Display Modes


Similar Threads
Thread Forum
99 carryall 2 not firing Gas Club Car
89 ez go gas firing poblem Gas EZGO
G8 motor not firing up Gas Yamaha
G14 Firing Problem Gas Yamaha
not firing Gas EZGO


All times are GMT -5. The time now is 04:47 PM.


Club Car Electric | EZGO Electric | Lifted Golf Carts | Gas EZGO | Used Golf Carts and Parts

Powered by vBulletin® Version 3.8.6
Copyright ©2000 - 2019, Jelsoft Enterprises Ltd.
Content Relevant URLs by vBSEO ©2011, Crawlability, Inc.