|
Gas Yamaha Gas Yamaha Golf Cars; G1 through "The Drive" and U-Max Utility Vehicles |
|
Thread Tools | Display Modes |
07-17-2008, 11:15 AM | #1 |
Not Yet Wild
Join Date: Jul 2008
Posts: 17
|
91 G9 has no power-HELP
Just got a 1991 G9 and I dont know anything about golf carts. The cart does not have any power when the gas pedal is pushed all the way down. It will only run about 10 MPH and struggles up small hills. The belt appears to be in good condition and is about 1 1/4" wide. The clutch appears to be working properly. Seems this is a fuel or fire problem. Where should I start. The cart is all stock no lift or aftermarket tires. How fast should this cart go? What would be the first thing to check?
|
Today | |
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
07-17-2008, 12:48 PM | #2 |
Admin/Moderator
Join Date: Dec 2006
Location: Ohio
Posts: 18,052
|
Re: 91 G9 has no power-HELP
Welcome to BGW!!
Check / replace fuel filter, air filter and spark plug. See if that helps. |
Ron
PLEASE VISIT Our Sponsors * BGW GEAR The Store The G2 Project * Swing Arm Drop & Repair * Geep1 Project |
|
07-17-2008, 01:02 PM | #3 |
Admin
Join Date: Dec 2006
Location: TN
Posts: 101,871
|
Re: 91 G9 has no power-HELP
Welcome to BGW!
Check to make sure your throttle on the carb. is opening up all the way when you press the gas pedal to the floor. Check it with the engine off and key out. If it is not opening all the way, adjust your throttle cables: 10mm. |
|
|
07-17-2008, 04:28 PM | #4 |
Not Yet Wild
Join Date: Jul 2008
Posts: 17
|
Re: 91 G9 has no power-HELP
Checked throttle cable, it is opening all the way. Checked plug, it was dry and not fouled. looked new. Checked air filter- looked good. I did find two of the rubber hold downs on the filter box are broken. Also found the fuel line from the pump to the carb has been replaced. It is 7/32". I have seen wrong size fuel lines can be a problem. Is this the wrong size? I have not checked the fuel filter yet. I did pull the fuel line from the carb and cranked engine. Pump appeared to be pumping fine.
|
07-17-2008, 04:30 PM | #5 |
Admin
Join Date: Dec 2006
Location: TN
Posts: 101,871
|
Re: 91 G9 has no power-HELP
Fuel line needs to be 5/16 and 1/4 on the Yamaha's. It will cause a problem due to the fuel pump working off vacuum. Also take a rubber tiedown strap and strap the air filter box lid down. Yamaha's are very touchy with air leaks.
The fuel filters on these are screwed into the bottom of the tank where the line goes in. I usually remove them, break out the old filter and install an inline filter between the pump and tank. |
|
|
07-17-2008, 11:46 PM | #6 |
Not Yet Wild
Join Date: Jul 2008
Posts: 17
|
Re: 91 G9 has no power-HELP
How do I determine which size to use? (IE-tank to pump, pump to carb, and vacuum line to pump). Also when driving the cart and I have the accelerator all the way down the engine feels as if it is surging (speeds up then slows down). It continually does this very quickly.
|
07-18-2008, 12:59 AM | #7 |
Not Yet Wild
Join Date: Jul 2008
Posts: 2
|
Re: 91 G9 has no power-HELP
my 94 G9 goes 14mph (GPS) and its bone stock
|
07-18-2008, 09:33 AM | #8 |
Gone Wild
Join Date: Aug 2007
Location: near sacramento,ca
Posts: 1,895
|
Re: 91 G9 has no power-HELP
surging is either a vacuum leak or your running out of gas. I would lean toward the vacuum leak as the carb carries enough gas in the bowl to run for a minute or two.
|
07-18-2008, 09:55 AM | #9 |
Admin/Moderator
Join Date: Dec 2006
Location: Ohio
Posts: 18,052
|
Re: 91 G9 has no power-HELP
|
Ron
PLEASE VISIT Our Sponsors * BGW GEAR The Store The G2 Project * Swing Arm Drop & Repair * Geep1 Project |
|
07-18-2008, 11:17 PM | #10 |
Not Yet Wild
Join Date: Jul 2008
Posts: 17
|
Re: 91 G9 has no power-HELP
Can anybody tell me which size fuel line? I seen 5/16 and 1/4" but dont know which one to use where. What size from pump to carb? Tank to pump? and vacum line to pump?
|
|
|
Similar Threads | ||||
Thread | Forum | |||
more power | Gas Yamaha | |||
More power | Extreme DC! | |||
help no power | Electric Yamaha | |||
No Power | Electric Club Car | |||
V-power gas... | Gas Yamaha |