|
Gas Yamaha Gas Yamaha Golf Cars; G1 through "The Drive" and U-Max Utility Vehicles |
|
Thread Tools | Display Modes |
10-12-2012, 05:58 PM | #1 |
Gone Wild
Join Date: Jan 2009
Location: Southern Maryland
Posts: 399
|
g14 clutch
My g14 sat with out a body outside for a while. Cleaned the tank, fuel pump, carb. Ran great but now the clutch closed up and is stuck. I did not move the cart just ran in neutral. I not sure where to start (wd 40, big pry bar, really big hammer, etc.). There is a annual golf cart and tractor parade sunday that I was hoping to go to until this happened. Any help would be appreciated.
Thanks Mike |
Today | |
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
10-12-2012, 06:58 PM | #2 | |
Sometime's............
Join Date: Oct 2007
Location: Tacoma Washington
Posts: 11,874
|
Re: g14 clutch
Quote:
|
|
10-12-2012, 09:16 PM | #3 |
Gone Wild
Join Date: Jan 2009
Location: Southern Maryland
Posts: 399
|
Re: g14 clutch
Yes the primary. I don't think anything broke just rusted and I do not know how to get it to move open so i can clean it and lube it . Also do not know what to use for lube, how much grease to use on the fittings.
Thanks Mike |
10-12-2012, 10:06 PM | #4 |
G8 Specialist
Join Date: Jun 2009
Location: Phoenix
Posts: 7,799
|
Re: g14 clutch
Mike, one ta two pumps from a grease gun. If prim., try moving it by hand, back and forth. Don't want to hit it. Might try taking off the outside cover to see if one of the 3 weights might be stuck.
If rear clutch (secondary) is froze, I'd try spraying the shaft inside the exposed spring with penatrating oil. Then again about, no more than 2 pumps of grease in the zirk fitting. |
Tags |
clutch, g14, stuck |
|
|
Similar Threads | ||||
Thread | Forum | |||
Clutch Help - G1 Drive Clutch Spring | Gas Yamaha | |||
Tips & Hints for installing Clutch Tuning Kit, Removal of Drive Clutch | Gas Club Car | |||
using hand clutch as foot clutch | Design Center | |||
stock ezgo clutch and yamaha clutch | Big Block Talk! | |||
Dive Clutch and Driven Clutch. Is this right?? | Gas EZGO |