|
Gas Yamaha Gas Yamaha Golf Cars; G1 through "The Drive" and U-Max Utility Vehicles |
|
Thread Tools | Display Modes |
08-12-2013, 04:27 PM | #1 |
Gone Wild
Join Date: Oct 2012
Location: Florida
Posts: 206
|
g1 refusing to turn over
ok i ll admit it, i suck with wiring! haha. i ve read the so your yami wont turn over thread but i feel lost. i tested to red/white and white wire at the accelerator switch and it passed that test. but when my cart is in reverse with the buzzer going, the buzzer cuts out when i hit the gas pedal and i cant get the generator to turn over.... wont work in forward either. no clicks either from solenoid. i did wrap a belt around the clutch and pulled and got a spark but its a pain trying to turn it over with the enticer head(higher compression) so can anyone help me out?!... btw its an 82 g1 gas
|
Today | |
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
08-12-2013, 06:52 PM | #2 |
Gone Wild
Join Date: Sep 2010
Location: Erie, Pennsylvania
Posts: 989
|
Re: g1 refusing to turn over
Before going any further, make sure your battery is fully charged and not defective. Then clean and tighten all high current connections (especially at the battery). After you are sure connections are clean and tight and battery is charged and tests OK, then troubleshoot if it won't turn over. Advise what you find. - RAY
|
08-12-2013, 08:20 PM | #3 |
Gone Wild
Join Date: Oct 2012
Location: Florida
Posts: 206
|
Re: g1 refusing to turn over
everything it tight and clean, the battery is at 12.45 sum sum volts... i have the manual but ikd just doesn't make to much sense to me i guess... dont read to good ;) haha also is there a way to bypass the solenoid to get the stater motor turning?
|
08-12-2013, 08:22 PM | #4 |
Searching for The Way
Join Date: Oct 2009
Location: Medina, Ohio (NEOHIO)
Posts: 11,441
|
Re: g1 refusing to turn over
The compression ratio on the enticer 250 isn't all that much higher than the G1. I don't think your problem has anything to do with the head, it's electrical. This was running, correct? I'm with the previous post, check the battery then bench test the starter/gen.
|
08-12-2013, 08:35 PM | #5 |
Gone Wild
Join Date: Oct 2012
Location: Florida
Posts: 206
|
Re: g1 refusing to turn over
lot higher than the 82 year! haha but yes it is defiantly electrical. and it was running before, really strong too. i was trying to get it to start by wrapping a rope around the clutch but no dice... how do you go about doing that bench test?...
|
08-12-2013, 08:39 PM | #6 |
Searching for The Way
Join Date: Oct 2009
Location: Medina, Ohio (NEOHIO)
Posts: 11,441
|
Re: g1 refusing to turn over
I'd take the starter/gen off and take it up to the local napa or az and they can bench test both the starter function and the generator function. They'll hook it up to a special vice that holds the starter and they connect power and ground to it, etc and can even run a belt to it to spin it and check the output. It's usually a free service.
|
08-12-2013, 08:44 PM | #7 |
Gone Wild
Join Date: Oct 2012
Location: Florida
Posts: 206
|
Re: g1 refusing to turn over
even better! haha any advice on checking the solenoids cuz i am getting no click from them and for example when its in reverse and its buzzing i hit the pedal and the buzzing stops. let go of the pedal and the buzzer comes back. could that be a sign of something?
|
08-12-2013, 08:48 PM | #8 |
Gone Wild
Join Date: Oct 2010
Posts: 6,730
|
Re: g1 refusing to turn over
Yes, it's a sign of a low battery or a loose connection. What's the battery voltage when you press the pedal?
|
08-12-2013, 08:53 PM | #9 |
Gone Wild
Join Date: Oct 2012
Location: Florida
Posts: 206
|
Re: g1 refusing to turn over
drops to about 11.7v
|
08-12-2013, 08:56 PM | #10 |
Gone Wild
Join Date: Oct 2010
Posts: 6,730
|
Re: g1 refusing to turn over
Whats the voltage between A1 and A2 on the starter when you press the pedal?
|
|
|
Similar Threads | ||||
Thread | Forum | |||
G2 will not turn over | Gas Yamaha | |||
G2 won't turn over | Gas Yamaha | |||
Wont turn left and now wont turn right | Electric EZGO | |||
Doesn't turn over | Gas Club Car | |||
G16 don't turn off | Gas Yamaha |