lifted club cars - lifted ezgo
Home FAQDonate Who's Online
Go Back   Buggies Gone Wild Golf Cart Forum > Golf Cart Repair and Troubleshooting > Gas Yamaha
Gas Yamaha Gas Yamaha Golf Cars; G1 through "The Drive" and U-Max Utility Vehicles



Post New Thread  Reply
 
Thread Tools Display Modes
Old 10-19-2008, 09:13 AM   #1
Getting Wild
Yamaha
 
Join Date: Oct 2008
Location: Heber Springs, ARKANSAS
Posts: 113
Smile 1989 Yamaha G2 carb adjustments

Hi .everyone! Just got into the cart world and have a question about my carb. Have done some of the basic tune-up things, ( plug, air filter/box, gov. "adjustment", ect), but still getting that rich smell while driving down the road (not overpowering, just stinks) Could a carb screw adjustment help resolve my problem. Any help would be great! Have fun carting around!
bubba1020 is offline   Reply With Quote
Alt Today
BGW

Golf car forum Sponsored Links

__________________
This advertising will not be shown in this way to registered members.
Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum
   
Old 10-19-2008, 11:07 AM   #2
Gone Wild
 
shawn.m's Avatar
 
Join Date: Aug 2007
Location: near sacramento,ca
Posts: 1,808
Default Re: 1989 Yamaha G2 carb adjustments

fixed main jet. only can adjust the idle on some of the carts
shawn.m is offline   Reply With Quote
Old 10-22-2008, 09:37 PM   #3
Getting Wild
Yamaha
 
Join Date: Oct 2008
Location: Heber Springs, ARKANSAS
Posts: 113
Default Re: 1989 Yamaha G2 carb adjustments

Thanks shawn!
bubba1020 is offline   Reply With Quote
Old 10-22-2008, 10:07 PM   #4
Gone Crazy
 
Join Date: Jan 2007
Location: Chesterfield, Va
Posts: 5,064
Default Re: 1989 Yamaha G2 carb adjustments

check for an exhaust leak. Some have added an extention to the little tail pipe to get it out the back more.
Might also check the gas tank, cap, vent, fuel lines for cracks where you might be smelling fumes mixed with exhaust. Mitch
crash12888 is offline   Reply With Quote
Old 10-23-2008, 10:39 AM   #5
Sometime's............
 
smallblock450sl's Avatar
Yamaha
 
Join Date: Oct 2007
Location: Tacoma Washington
Posts: 8,090
Default Re: 1989 Yamaha G2 carb adjustments

Theres only two adjustments on the carb. throttle stop screw and pilot adjustment screw. Take the pilot adjustment screw and spring out and make shure it has a very "sharp" point, if it has a "flat" spot ,its damaged and replace it. Screw it back in till "Lightly seated" then turn out 1 1/2 turns. Thats the stock setting. Hope it helps Dave
smallblock450sl is offline   Reply With Quote
Old 10-23-2008, 08:47 PM   #6
Getting Wild
Yamaha
 
Join Date: Oct 2008
Location: Heber Springs, ARKANSAS
Posts: 113
Default Re: 1989 Yamaha G2 carb adjustments

Thanks for the info!!!!!!!!!! That fixed it right up!!!!!!!!! Now when i start it cold in the morning, my choke cable has become difficult to pull out. Need some grease? Could it be in a bind? Any and All help and constructive criticism accepted!!!!!!!!!!!!!! Still lovin' my yammy G2!!!!!!!!!!!!!!!!!!!!!!!!
bubba1020 is offline   Reply With Quote
Old 10-23-2008, 10:09 PM   #7
Gone Crazy
 
Join Date: Jan 2007
Location: Chesterfield, Va
Posts: 5,064
Default Re: 1989 Yamaha G2 carb adjustments

cable could be binding when you close the seat frame
cable could be dry and need a good shot of WD40
cable could be fine but choke shaft on carb dragging.

Usually the cable is dry. Need to take it off and hang it vertical so you can gravity feed WD down the inner cable all the way through
Spray, let it sit, work it up and down, spray, let it sit, work it up and down, keep doing it until you don't see any rust running out.
crash12888 is offline   Reply With Quote
Old 10-24-2008, 04:22 AM   #8
Getting Wild
Yamaha
 
Join Date: Oct 2008
Location: Heber Springs, ARKANSAS
Posts: 113
Default Re: 1989 Yamaha G2 carb adjustments

Thanks crash! Worked out great! Now if I could only fix that wobbly rear wheel that keeps throwing me off the #@%* cart...........................Ha Ha!!!!
bubba1020 is offline   Reply With Quote
Old 10-29-2008, 01:06 AM   #9
Gone Wild
 
Wynelocked's Avatar
Yamaha
 
Join Date: Jun 2008
Location: New Braunfels,Texas
Posts: 156
Default Re: 1989 Yamaha G2 carb adjustments

Quote:
Originally Posted by bubba1020 View Post
Thanks crash! Worked out great! Now if I could only fix that wobbly rear wheel that keeps throwing me off the #@%* cart...........................Ha Ha!!!!


Tires an wheels are cheap...get a new one.
Wynelocked is offline   Reply With Quote
Old 10-29-2008, 01:25 PM   #10
Getting Wild
Yamaha
 
Join Date: Oct 2008
Location: Heber Springs, ARKANSAS
Posts: 113
Default Re: 1989 Yamaha G2 carb adjustments

just making a funny.ha ha.
bubba1020 is offline   Reply With Quote
Reply
Go Back   Buggies Gone Wild Golf Cart Forum > Golf Cart Repair and Troubleshooting > Gas Yamaha


Thread Tools
Display Modes


Similar Threads
Thread Forum
What adjustments for speed? Electric EZGO
G1 Carb. jet on outside of carb ? What the Heck ? Gas Yamaha
WANTED Yamaha G2/G9 carb & drive clutch Golf Carts and Parts
1989 2-stroke Gas EZGO
1989 ez go no power Electric EZGO


All times are GMT -5. The time now is 08:28 AM.


Club Car Electric | EZGO Electric | Lifted Golf Carts | Gas EZGO | Used Golf Carts and Parts

Powered by vBulletin® Version 3.8.6
Copyright ©2000 - 2014, Jelsoft Enterprises Ltd.
Content Relevant URLs by vBSEO ©2011, Crawlability, Inc.