|
Gas Yamaha Gas Yamaha Golf Cars; G1 through "The Drive" and U-Max Utility Vehicles |
|
Thread Tools | Display Modes |
09-01-2014, 02:18 PM | #1 |
Not Yet Wild
Join Date: Aug 2014
Posts: 29
|
G 1 died while running
I had issues with the cart only running wide open. I got some help on here and made a new throttle shaft bushing, ran better than it ever had. Then I decided to burn out the muffler and unhook the oil pump and used mixed gas. I mixed it about 80/1 (2oz oil/gallon of premium gas). Started and ran great, drove it over 3/4 mile, no problems. Took my wife for a ride and it started running rough and died1/4 mile from home. Pulled it home and checked things over. Good fire to plug, gas to carb, took carb off and cleaned , no go. I tried spraying some WD40 in the carb while cranking, still no go. When cranking it over, I noticed a lot of oil puffing out below carb. There are 2 small tubes sticking out of the crank case below the carb, one has a hose that runs up to the piece the carb hooks onto. the other is clean, meaning it has been used, but I can't find any hose to hook it to. I put a hose with a plugged end on it, still no start. Where do I look next, I'm lost?? Thanks, Chris
|
Today | |
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
09-01-2014, 02:27 PM | #2 |
Gone Wild
Join Date: Oct 2010
Posts: 6,730
|
Re: G 1 died while running
2oz/gallon is 64:1 ratio. Way too much oil. Remix fuel and try a new plug.
|
09-01-2014, 05:59 PM | #3 |
Not Yet Wild
Join Date: Aug 2014
Posts: 29
|
Re: G 1 died while running
OK, I guess I didn't calculate the amount correctly. I ran a compression check on it and it has 100#'s. I cleaned the spark plug while it was out and put it back in and tried it, it finally started and ran poorly for a little bit, backfired and died. I'm trying to post a picture of the hose barb sticking out of the crankcase, not sure if it will post or not. I will drain the gas and remix it and try again. Chris
|
09-01-2014, 06:08 PM | #4 |
Gone Wild
Join Date: Oct 2010
Posts: 6,730
|
Re: G 1 died while running
Isn't that port supposed to run the fuel pump?
|
09-01-2014, 06:31 PM | #5 |
Not Yet Wild
Join Date: Aug 2014
Posts: 29
|
Re: G 1 died while running
I don't know, it has been converted to an electric fuel pump before I got it. I never noticed this before, don't know if it was plugged or not. I wonder if it came off when it backfired?
|
09-01-2014, 06:33 PM | #6 |
Gone Wild
Join Date: Oct 2010
Posts: 6,730
|
Re: G 1 died while running
Did you remix the fuel and try a new plug? Not a different plug, a new plug.
|
09-01-2014, 07:49 PM | #7 |
Not Yet Wild
Join Date: Aug 2014
Posts: 29
|
Re: G 1 died while running
Not yet. I'll stop after work tomorrow and get a new spark plug and another 5 gal of gas to mix with. The old tractors won't mind the gas I drain out. The chart I have says 50:1 takes 2.6oz/gal, 100:1 takes 1.3oz/gal. I put 7 oz in a 5 gal can and will fill it with new gas and try that. Thanks, Chris
|
09-05-2014, 05:48 PM | #8 |
Not Yet Wild
Join Date: Sep 2012
Location: Sioux Falls, SD
Posts: 20
|
Re: G 1 died while running
If it has a electric fuel pump I would think both of those ports should be plugged? Otherwise you have a leak and the air fuel will not mix, correct?
|
09-05-2014, 05:58 PM | #9 |
Gone Wild
Join Date: Oct 2010
Posts: 6,730
|
Re: G 1 died while running
|
|
|
Similar Threads | ||||
Thread | Forum | |||
cart died after running problem free for the season | Gas Yamaha | |||
it died | Gas EZGO | |||
93 CC died won't start | Gas Club Car | |||
'85 Club Car Died | Electric Club Car | |||
just died on me. | Gas EZGO |