lifted club cars - lifted ezgo
Home FAQDonate Who's Online
Go Back   Buggies Gone Wild Golf Cart Forum > Golf Cart Repair and Troubleshooting > Gas Yamaha
Gas Yamaha Gas Yamaha Golf Cars; G1 through "The Drive" and U-Max Utility Vehicles



Post New Thread  Reply
Thread Tools Display Modes
Unread 10-13-2014, 08:46 PM   #11
Gone Wild
 
duramax's Avatar
 
Join Date: Mar 2014
Location: S.W. Florida
Posts: 296
Default Re: g-16 fuelpump

i was told to do that by the local shop but i also replaced it just incase their were any vacume leaks
duramax is offline   Reply With Quote
Alt Today
BGW

Golf car forum Sponsored Links

__________________
This advertising will not be shown in this way to registered members.
Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum
   
Unread 10-14-2014, 11:21 AM   #12
Gone Wild
 
sjfishon's Avatar
Yamaha
 
Join Date: Sep 2013
Posts: 232
Default Re: g-16 fuelpump

i was a little wrong in my last reply.sorry;;; my filter sits level, it never fills, i don't think there is enough pressure to fill it.. when the engine is running, there is about one quarter of the filter filled across the bottom,, i was concerned about that, thinking it should be full. but the cart runs perfect,, what i do ,is every few months i just twist the filter so its clean at the bottom.... hope this helps,,
sjfishon is offline   Reply With Quote
Unread 10-14-2014, 08:18 PM   #13
Gone Wild
 
duramax's Avatar
 
Join Date: Mar 2014
Location: S.W. Florida
Posts: 296
Default Re: g-16 fuelpump

most of the time i dont see any fuel in mine but you can tell the paper is wet im going to try the eletric pump next week when i get time off if it doesnt work ill just take it off no big deal
duramax is offline   Reply With Quote
Unread 10-14-2014, 08:59 PM   #14
G8 Specialist
Yamaha
 
Join Date: Jun 2009
Location: Phoenix
Posts: 7,722
Default Re: g-16 fuelpump

Just purge the air out, if you want to gone.
Mike Mac is offline   Reply With Quote
Unread 10-16-2014, 11:23 AM   #15
Gone Wild
 
sjfishon's Avatar
Yamaha
 
Join Date: Sep 2013
Posts: 232
Default Re: g-16 fuelpump

i think the issue is the very small amount of fuel pump pressure.. as long as the gas line going out of the fuel pump stays full ,,towards the carb, the engine will run fine,, i bet a new cart will show a empty fuel filter,, that's why i turn my filter once in a while,, i looked at my riding lawn mower,, the filter has no gas in it either,, but it runs perfect. i do think an electric, is way overkill,, it could even cause problems with the carb, float??? if you think you are having trouble with it,, take the filter out and see how the engine runs, there is even a very small inline filter , you might like, you cant even see in it,, whats important is how it runs;; good luck
sjfishon is offline   Reply With Quote
Unread 11-08-2014, 08:39 PM   #16
Gone Wild
 
duramax's Avatar
 
Join Date: Mar 2014
Location: S.W. Florida
Posts: 296
Default Re: g-16 fuelpump

whell i installed my low psi eletric fuel pump between my gas tank & the factory pump & all my problems are gone it doesnt starve for fuel on the steep hills. it will hold 13 mph on a 600 ft climb & tops out at 31 on pavement. i wired the pump to only run when the gas petal is depressed so it doesnt flood the carb. it only builds 1 psi pressure & i also have the factory pump as a restrictor. this is the best it has run since i got it. put almost 60 miles on it in 2 weeks & no problems yet. you can see the new pump under the forward reverse switch.
Attached Images
File Type: jpg 100_2468.jpg (189.5 KB, 0 views)
duramax is offline   Reply With Quote
Reply
Go Back   Buggies Gone Wild Golf Cart Forum > Golf Cart Repair and Troubleshooting > Gas Yamaha


Thread Tools
Display Modes



All times are GMT -5. The time now is 05:00 PM.


Club Car Electric | EZGO Electric | Lifted Golf Carts | Gas EZGO | Used Golf Carts and Parts

Powered by vBulletin® Version 3.8.6
Copyright ©2000 - 2017, Jelsoft Enterprises Ltd.
Content Relevant URLs by vBSEO ©2011, Crawlability, Inc.