1994 club car ds not running
i have a 1994 club car ds with brand new batteries in it. it doesn't run or even a click from the solenoid when you push the pedal. As soon as you jump the solenoid from large post to large post it takes off even with the key off and pedal still up. Does anyone have a clue what this may be or where to lead me
|
Re: 1994 club car ds not running
Tell us a bit more about the history of the cart. It should be a controller cart with no resistor coils. Is this correct?
Also, that cart is subject to take off any minute. At a minimum, jack the rear wheels off the ground and make sure it is in neutral. |
Re: 1994 club car ds not running
i just purchased the cart so the history on it is a blank to me as well and wasnt running before i got bought it. and it has a resistor board not a controller which im not super familiar with so any advice would be great thank you in advance
|
Re: 1994 club car ds not running
What is the serial number on the cart? Please post some photos of the battery compartment and the resistor coils.
|
Re: 1994 club car ds not running
how do you upload a picture? and the serial number is a9436 399761
|
Re: 1994 club car ds not running
That is a pretty simple system to fix, do the following:
Raise one rear wheel off the ground for safety. Measure the voltage between the two Solenoid small posts. If You have +36v, replace the Solenoid. If You don't have +36v between the Solenoid small posts:
Otherwise: 1994 with negative key Switch:Measure the voltage between the Solenoid small post with the Green wire (red meter probe) and the pack negative battery post (black meter probe).1995+ with positive key Switch: Here is the 1995 (positive key switch) wiring diagram for reference:
Here is the 1994 (Negative Key Switch) wiring diagram for reference: https://www.buggiesgonewild.com/atta...640340&thumb=1 |
Re: 1994 club car ds not running
Quote:
The reason I asked for the serial number and photo is because every 1994 Club Car I have ever seen has a controller. :shock: |
Re: 1994 club car ds not running
Quote:
I will edit the original post to include the colors for the early 1994 negative key switch to be safe :thumbup: |
Re: 1994 club car ds not running
i replaced both microswitches and still have nothing no solenoid click and no movement
|
Re: 1994 club car ds not running
What were your voltage results from the tests above?
|
All times are GMT -5. The time now is 08:33 AM. |
Powered by vBulletin® Version 3.8.9
Copyright ©2000 - 2024, vBulletin Solutions, Inc.
This Website and forum is the property of Buggiesgonewild.com. No material may be taken or duplicated in part or full without prior written consent of the owners of buggiesgonewild.com. © 2006-2017 Buggiesgonewild.com. All rights reserved.