94 Club Car Gas Throttle Problem
 

Hi everyone, I have a 94 cart that for some reason goes full throttle when you touch the gas pedal. I think I have narrowed it down to the RPM limiter but that is an expensive part to not be sure. I have searched everywhere for a troubleshooting guide to help me determine if I am right but have had no luck. Anyone know how to test that particular part or have the guide? I would really appreciate it.

Re: 94 Club Car Gas Throttle Problem
 

Have you looked inside your carb to make sure your butterfly valve is in tact and working properly?

Re: 94 Club Car Gas Throttle Problem
 

Thanks that was the problem

Re: 94 Club Car Gas Throttle Problem
 

Glad I could help!

Re: 94 Club Car Gas Throttle Problem
 

I have the same problem. I have taken the carb off and looked at the butterfly valve. Mine has only one side / half moon, is this correct?
or have I sucked the other half into the piston?

Re: 94 Club Car Gas Throttle Problem
 

If you only have half, yes, that's the problem. Without the full throttle plate it will run wide open. No idea where the other half is though.

Did you own it and it ran fine then suddenly it only ran wide open?

Re: 94 Club Car Gas Throttle Problem
 

If you got lucky, it went out the exhaust pipe faster than an Olympic sprinter hitting the finish tape. But if not; That evil minded piece of brass might be lurking just under the surface ready to rape your engine.

Chris.

Re: 94 Club Car Gas Throttle Problem
 

Yes, I have owened the cart for a few years. Guess I'll pull the head and take a look. plus get a new butterfly plate.

Thanks Gang

Re: 94 Club Car Gas Throttle Problem
 

geez kinda of harsh on the words! but yet it gets the point out there! simple too!