1984 ezgo two stroke
 

:banghead:I have a 1984 ezgo two stroke, I have a newly rebiult I installed an elecric fuel pump,( I was going to convert to 20 hp 4 stroke) but I rebuilt the two stroke. Cart ran great for two weeks. I left the cart at the lake so my buddy could use it. When I returned would not start. checked everything,no spark so I replaced the coil pack. It started and ran for one minute,then dies. it will start right back up and dies. So I relaced the solenoid and battery today.
same problem, this is driving me nuts.

Re: help me
 

You might want to check the carb!!!!!!!!!!!!!!! and fuel filter

Re: help me
 

I think there is an igniter (sp) on that cart. may want to check that.

Re: help me
 

the carb has just been rebuilt , the fuel filter is new. Where is this igniter ??

Re: help me
 

I'm not sure, we need an ez-go guy to jump in here!!!!

Re: help me
 

I can only assume the igniter has gone bad, it looks like a small cube with 5 wires comming out of it (I think). It should be next to the voltage regulator. I haven't seen one of those carts in an easy 20 years or so any info from me would be a guess. You can pm Bob-O, he may know about it. I know he has worked on some of the older carts. look up his name in the members list.

Re: help me
 

did you take the head off? I know with 2 stroke dirtbikes the head has to be torqued down to a certain spec or it gets too high of a compression.

Re: help me
 

I have not taken the head off , I will try the igniter. Thanks for the ideas guys.

Re: help me
 

IF you find the ignitor to be a problem, I have a good, used one I am willing to sell. PM me if interested.

Re: help me
 

just in case how much??