Buggies Gone Wild Golf Cart Forum
Page 1 of 2 1 2 >
Show 40 post(s) from this thread on one page

Buggies Gone Wild Golf Cart Forum (https://www.buggiesgonewild.com/index.php)
-   Electric EZGO (https://www.buggiesgonewild.com/forumdisplay.php?f=16)
-   -   3Beeps then 2 (https://www.buggiesgonewild.com/showthread.php?t=119063)

Wynelocked 06-04-2016 11:38 AM
3Beeps then 2
 
I'm getting this when I plug in the charger.Whats going on here guys?

It's a 2000 PDS 36V

crash test dummy 06-04-2016 12:50 PM
Re: 3Beeps then 2
 
what type of charger



..........http://i751.photobucket.com/albums/x...0/golfcart.gif

JohnnieB 06-04-2016 01:41 PM
Re: 3Beeps then 2
 
1 Attachment(s)
Beeping 3-2 is the error code for a wielded solenoid, but low voltage on J1 Pin-5 will also set that error flag.

What the controller is doing is comparing the voltage between the controller's B- and B+ terminals vs the voltage between the controller's B- terminal and J1 Pin-5 (Bottom row -far left - plug is mounted upside down - see attached).

When the solenoid contacts are open, the voltage on the B+ terminal should be less than the voltage on Pin-5 and when the solenoid contacts are closed, they should be the same.

What voltages do you get?

---------
Not sure why you are getting a beeped error code if the key is off, as it should be while charging.

Wynelocked 06-04-2016 04:20 PM
Re: 3Beeps then 2
 
Quote:
Originally Posted by JohnnieB (Post 1281616)
Beeping 3-2 is the error code for a wielded solenoid, but low voltage on J1 Pin-5 will also set that error flag.

What the controller is doing is comparing the voltage between the controller's B- and B+ terminals vs the voltage between the controller's B- terminal and J1 Pin-5 (Bottom row -far left - plug is mounted upside down - see attached).

When the solenoid contacts are open, the voltage on the B+ terminal should be less than the voltage on Pin-5 and when the solenoid contacts are closed, they should be the same.

What voltages do you get?

---------
Not sure why you are getting a beeped error code if the key is off, as it should be while charging.
Have to break out the voltmeter..

Key is on...should it be off always when charging?I know at our golf course we dont even have keys...they are always on.

Wynelocked 06-04-2016 04:26 PM
Re: 3Beeps then 2
 
JohnnieB...I have been fighting this go no go cart situation.Every time I think I fixed it...it does it again.This beeping is new now.I just bypassed the reed switch.Last week in fact...thought that was it.Cart ran perfect..then started the go... no go action again.The reverse buzzer worked even when the cart dont.Before I replaced some bad cables...the buzzer never worked when the cart would not run.

I think I have the origional GHOST cart

JohnnieB 06-04-2016 04:58 PM
Re: 3Beeps then 2
 
Quote:
Originally Posted by Wynelocked (Post 1281659)
Have to break out the voltmeter..

Key is on...should it be off always when charging?I know at our golf course we dont even have keys...they are always on.
I may be wrong about the key needing to be off when charging, I checked the owner and the service manuals for 36V PDS carts and nothing was mentioned about charging with the key on.

On the other hand, I always turn the key off and place the F/R in neutral when I park my cart, just in case the throttle pedal get bumped.

Wynelocked 06-04-2016 11:49 PM
Re: 3Beeps then 2
 
Quote:
Originally Posted by JohnnieB (Post 1281673)
I may be wrong about the key needing to be off when charging, I checked the owner and the service manuals for 36V PDS carts and nothing was mentioned about charging with the key on.

On the other hand, I always turn the key off and place the F/R in neutral when I park my cart, just in case the throttle pedal get bumped.
prolly good advice

Wynelocked 06-05-2016 10:58 AM
Re: 3Beeps then 2
 
Quote:
Originally Posted by crash test dummy (Post 1281603)

powerwise

Wynelocked 06-05-2016 10:59 AM
Re: 3Beeps then 2
 
Stupid thing is fine today....

crash test dummy 06-05-2016 11:18 AM
Re: 3Beeps then 2
 
our work carts always are charged with the key on .. so i can glance at the meter and see volts
i do believe you have a gremlin http://retrogifs.com/gifs/Gremlin/GREMPRP3.GIF


All times are GMT -5. The time now is 07:14 PM.
Page 1 of 2 1 2 >
Show 40 post(s) from this thread on one page

Powered by vBulletin® Version 3.8.9
Copyright ©2000 - 2024, vBulletin Solutions, Inc.
This Website and forum is the property of Buggiesgonewild.com. No material may be taken or duplicated in part or full without prior written consent of the owners of buggiesgonewild.com. © 2006-2017 Buggiesgonewild.com. All rights reserved.