1988 4 wheel gas not running
I baught this golf cart from an old guy who had it running when we got there. The only thing is he said you needed to get it warmed up to get it goin. So I drove it up and down his lane and then we took it home. At home it seems it doesnt matter if you warm it up, it still wont ever go.
The guy said it needed some kind of gasket in the engine. Does this make sence to any one. When you put in forward you can let the electric motor crank the engine all you want, but it doesnt ever start, even with choke. Thanks |
Re: 1988 4 wheel gas not running
check for fuel, spark, and compression. If you dont have compression it wont start.
pics help |
Re: 1988 4 wheel gas not running
Ok so I got some time to work on the cart, not much time but some. I now know it has spark, but Im not sure on how to check the gas. It has no fuel pump, and i dont know how to check to see if it is getting gas. It must be off of vacuum, but I dont know.
Also I sprayed starting fluid in the carb, and it didnt even kick over. it just cranked on the electric motor. So if yall can give me a leaping off point that would help. Thanks, |
Re: 1988 4 wheel gas not running
Sounds like compression is all that is left. It should run around 90 pounds to 100 pounds. It should run with 70 or 75 pounds but should have new rings. Pull the top end if compression is low pull the top end and check for a scored cylinder or worn rings. Check the ring gap with a new set. Ring Gap should be around .007 to .020
|
Re: 1988 4 wheel gas not running
are the rings and gaskets easy to come by? I am wanting this thing to be ready in a week.
|
Re: 1988 4 wheel gas not running
pull the exhaust and take a look at the piston.
|
Re: 1988 4 wheel gas not running
Quote:
it runs but not perect yet. You can get the part pretty easy, but are you shure you dont have a fuel pump. http://www.golfcartcare.com/Merchant...00001/5304.jpg http://www.buggiesgonewild.com/attac...ebuild-001.jpg http://www.buggiesgonewild.com/attac...ld-002.jpgp:// |
Re: 1988 4 wheel gas not running
there is a tube that goes into the gas tank and there is nothing on the end of it. It runs to block that has a tube from the oil tank, and another couple tubes running the the engine.
|
Re: 1988 4 wheel gas not running
I would get a compression reading before anything else is done.
Unscrew the spark plug and put a little gas mixture in the cylinder replace the plug and see if it will start. Put a little oil in the cylinder first to wet the cylinder walls then the fuel. It might start. |
Re: 1988 4 wheel gas not running
Quote:
|
All times are GMT -5. The time now is 05:18 PM. |
Powered by vBulletin® Version 3.8.9
Copyright ©2000 - 2024, vBulletin Solutions, Inc.
This Website and forum is the property of Buggiesgonewild.com. No material may be taken or duplicated in part or full without prior written consent of the owners of buggiesgonewild.com. © 2006-2017 Buggiesgonewild.com. All rights reserved.