mcore access on 2001 club car ds

claymd54 · 10-03-2017, 04:06 PM

Hi All,

I just recently purchased a 2001 club car ds and it hesitates, i understand that indicates that the mcore is going bad. How do i get to the mcore on a 2001 club car ds? I don't see an access panel under the mat nor any screws holding the floor down.

Any help in pointing me in the right direction would be greatly appreciated!

Clay

BTW - followed peoples advice on my front end problems, replaced all the bushings, and the steering is nice and tight now. Thank you for this!

joesam · 10-03-2017, 06:57 PM

Unless your cart has been changed, you won't have a MCOR. You will have either:
a) If 36 volt resistor type - a V-Glide
b) If 36 volt controller type - A Multi-step Potentiometer
c) If 48 volt - Also a Multi Step Potentiometer

All of them are located in a pie-shaped plastic box between batteries below the driver seat. They can be replaced...or (if not totally shot) serviced.

People will need more info from you for someone to help...Is it 36 volt or 48 volt?

Serial number will be most helpful too - it will determine your drive system (there were 4 different drive systems in 2001).

TahoeDawgZ71 · 10-03-2017, 08:51 PM

You get to it from underneath the car on a DS. Jack the front end up in the air and lay down underneath it. It's bolted to the passenger side I-Beam beneath the floor. AM293101 is the correct replacement kit for your car.

joesam · 10-03-2017, 09:15 PM

I could have sworn 2001 was multi-step. CVP was gone by late '99 I thought.

TahoeDawgZ71 · 10-04-2017, 10:59 AM

Quote:

Originally Posted by joesam

I could have sworn 2001 was multi-step. CVP was gone by late '99 I thought.

We're both right. I knew 2001 was the transition year but I forgot that it happened during the middle of the year somewhere. I can't find the serial number cut-off anywhere for the CVP. The 2001 book shows both.

Sergio · 10-04-2017, 11:54 AM

I had looked that up before, Serial numbers after AA0112-001470 had MCORs.

claymd54 · 10-04-2017, 12:48 PM

Hi All,

Thanks for the info, my cart is a 48v, the vin is AC0132-046925.

Clay

TahoeDawgZ71 · 10-04-2017, 02:46 PM

Quote:

Originally Posted by claymd54

Hi All,

Thanks for the info, my cart is a 48v, the vin is AC0132-046925.

Clay

It has an MCOR then.

10-03-2017, 04:06 PM	#1
claymd54 Not Yet Wild Join Date: Sep 2017 Location: Frederick Md area Posts: 6	mcore access on 2001 club car ds Hi All, I just recently purchased a 2001 club car ds and it hesitates, i understand that indicates that the mcore is going bad. How do i get to the mcore on a 2001 club car ds? I don't see an access panel under the mat nor any screws holding the floor down. Any help in pointing me in the right direction would be greatly appreciated! Clay BTW - followed peoples advice on my front end problems, replaced all the bushings, and the steering is nice and tight now. Thank you for this!

10-03-2017, 06:57 PM	#2
joesam Gone Wild Join Date: Sep 2012 Location: Chestermere, Alberta - Canada Posts: 1,146	Re: mcore access on 2001 club car ds Unless your cart has been changed, you won't have a MCOR. You will have either: a) If 36 volt resistor type - a V-Glide b) If 36 volt controller type - A Multi-step Potentiometer c) If 48 volt - Also a Multi Step Potentiometer All of them are located in a pie-shaped plastic box between batteries below the driver seat. They can be replaced...or (if not totally shot) serviced. People will need more info from you for someone to help...Is it 36 volt or 48 volt? Serial number will be most helpful too - it will determine your drive system (there were 4 different drive systems in 2001).

10-03-2017, 08:51 PM	#3
TahoeDawgZ71 revolutiongolfcars.com Join Date: Mar 2010 Location: Golf Car Capital of The World... Augusta, Georgia Posts: 10,224	Re: mcore access on 2001 club car ds You get to it from underneath the car on a DS. Jack the front end up in the air and lay down underneath it. It's bolted to the passenger side I-Beam beneath the floor. AM293101 is the correct replacement kit for your car.

10-03-2017, 09:15 PM	#4
joesam Gone Wild Join Date: Sep 2012 Location: Chestermere, Alberta - Canada Posts: 1,146	Re: mcore access on 2001 club car ds I could have sworn 2001 was multi-step. CVP was gone by late '99 I thought.

10-04-2017, 11:54 AM	#6
Sergio Gone Wild Join Date: Sep 2012 Location: Charlotte, NC Posts: 9,329	Re: mcore access on 2001 club car ds I had looked that up before, Serial numbers after AA0112-001470 had MCORs.

Today
BGW	Sponsored Links __________________ This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum

10-04-2017, 12:48 PM	#7
claymd54 Not Yet Wild Join Date: Sep 2017 Location: Frederick Md area Posts: 6	Re: mcore access on 2001 club car ds Hi All, Thanks for the info, my cart is a 48v, the vin is AC0132-046925. Clay

Thread Tools
Show Printable Version Email this Page
Display Modes
Linear Mode Switch to Hybrid Mode Switch to Threaded Mode

Similar Threads
Thread	Forum
mcore?	Electric Club Car
Club Car Precedent Brake Access Panel	Electric Club Car
Can't access the Access Panel - Rivet Issues	Electric Yamaha
WTB: Club Car DS (2006) Access Panel Kit	Golf Carts and Parts
WTB: Access cover to fit a 2001 ezgo txt	Golf Carts and Parts