|
Electric EZGO Electric EZ GO Marathon, Medalist, TXT and RXV. |
|
Thread Tools | Display Modes |
10-27-2017, 04:09 PM | #1 |
Not Yet Wild
Join Date: Sep 2017
Location: West Grove, PA
Posts: 10
|
08 RXV not charging
I got a 08 RXV 48v cart with a charging issue, the red light on the charger flashes twice. The batteries are at 48 volts and i already replaced the charge receptacle. Never messed with one of these so any help or wiring diagrams would be appreciated.
Thanks |
Today | |
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
10-27-2017, 08:58 PM | #2 | |
Gone Insane
Join Date: Oct 2015
Location: TN/NC/GA Tri-state area
Posts: 3,952
|
Re: 08 RXV not charging
Quote:
http://shop.cartsunlimited.net/DPI-A...harger-DPI.htm I bought one for my RXV, it's the best! |
|
10-30-2017, 07:23 AM | #3 |
Gone Wild
Join Date: Oct 2008
Location: East Texas
Posts: 586
|
Re: 08 RXV not charging
I believe the two red flashes mean battery pack is either under voltage or way over voltage. Check all of your connections on the batteries and make sure everything is good and clean. Also check for continuity on the gray wire from the charge receptacle to the main pack positive. Hope this helps.
|
10-30-2017, 09:14 AM | #4 | |
Not Yet Wild
Join Date: Sep 2017
Location: West Grove, PA
Posts: 10
|
Re: 08 RXV not charging
Quote:
|
|
10-30-2017, 09:21 AM | #5 | |
Not Yet Wild
Join Date: Sep 2017
Location: West Grove, PA
Posts: 10
|
Re: 08 RXV not charging
Quote:
|
|
10-30-2017, 10:00 AM | #6 |
Gone Wild
Join Date: Oct 2008
Location: East Texas
Posts: 586
|
Re: 08 RXV not charging
Just ohm out the gray wire from the back of the charge port to the main pack positive. I believe it has a rectangular black plastic end on that wire where it connects to the battery. I think that rectangle is a resistor or something and if it is open, the battery charger will get two red flashes. I had it do that on one of my neighbors carts last year. I had to replace the wiring from the charge port to the battery pack to get it to work.
|
10-30-2017, 10:48 AM | #7 | |
Not Yet Wild
Join Date: Sep 2017
Location: West Grove, PA
Posts: 10
|
Re: 08 RXV not charging
Quote:
|
|
10-30-2017, 11:02 AM | #8 |
Gone Wild
Join Date: Oct 2008
Location: East Texas
Posts: 586
|
Re: 08 RXV not charging
I think it was almost a dead short measuring from the back of the receptacle to the battery, so just very few ohms if I remember correctly. I was able to get the entire wiring harness from a local dealer to replace it.
|
10-30-2017, 12:05 PM | #9 |
Not Yet Wild
Join Date: Sep 2017
Location: West Grove, PA
Posts: 10
|
Re: 08 RXV not charging
I replaced the original receptacle and wiring with a new one, then after some testing i found that there was no power supply to the blue wire, so i proceeded to replace it again
|
10-30-2017, 05:20 PM | #10 |
Getting Wild
Join Date: Mar 2017
Location: Windsor, Co
Posts: 110
|
Re: 08 RXV not charging
How old are the batteries? I had the same error, the batteries weren’t hold a charge. Put new ones in and the error went away. Load tested those old ones and dropped 2 volts in a couple seconds, wouldn’t hold a full charge when charging them separately either
|
|
Thread Tools | |
Display Modes | |
|
Similar Threads | ||||
Thread | Forum | |||
1997 electric 48v club car charging not charging my batteries? | Electric Club Car | |||
charging too much ? | Gas EZGO | |||
Charging | Electric EZGO | |||
2006 TXT 20+amps but not charging, hot charging cable | Electric EZGO | |||
Battery Charging Question (How to keep from over-charging) | Electric EZGO |