|
|
|||||||
| Gas EZGO Gas EZGO Marathon, Medalist, TXT and RXV. |
  |
|
|
Thread Tools | Display Modes |
08-05-2012, 08:20 PM
|
#1 |
|
Not Yet Wild
Join Date: Aug 2012
Posts: 5
|
have to choke every time
We have a 94 ezgo 4cyl and we have to choke it everytime to start and sometimes we have to take the spark plug out crank and and put the spark plug back in we are going to try the valve adjustment tomorrow anymore suggestions and what is the compression?
|
|
|
 Today
|
|
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
|
08-05-2012, 09:22 PM
|
#2 |
|
I Refuse To Get Stuck!!!
Join Date: Jun 2010
Location: Hilton,NY
Posts: 5,427
|
Re: have to choke every time
Sounds like carb/fuel-pump issues.If it looses prime you will have to choke it alot.Removing the plug allows it to crank faster.I would pull the fuel-line at the carb,aim it into a container(make sure the spark-plug is installed and connected or you'll need more than a small repair!---BOOM!!!)crank the engine and check flow,if its' very slow and weak,the pump is likely due for a rebuild.The compression should be at minimum 90psi per cyl.I'm not sure of the actual spec.Really low compression,due to worn rings or a valve-issue(bad-valve/seat) will cause a pump-pulse issue.Hope this helps.
 |
|
|
|
|
08-06-2012, 06:43 AM
|
#3 |
|
Not Yet Wild
Join Date: Aug 2012
Posts: 5
|
Re: have to choke every time
thanks will try that and see what happens:
|
|
|
|
|
08-06-2012, 07:11 AM
|
#4 |
|
Gone Wild
 Join Date: Sep 2010
Location: Florida
Posts: 1,895
|
Re: have to choke every time
compression should be between 120-150, but will crank with as low as 90 as pachanga stated...another thing you can try if above does not work would be to jet the carb...
|
|
|
|
|
08-06-2012, 10:03 AM
|
#5 |
|
Not Yet Wild
Join Date: Aug 2012
Posts: 5
|
Re: have to choke every time
thanks will try anything
|
|
|
|
|
08-06-2012, 06:53 PM
|
#6 |
|
Not Yet Wild
Join Date: Aug 2012
Posts: 5
|
Re: have to choke every time
thanks to all for the good advice valves were way off adjusted and runs great
|
|
|
|
|
|
||||||
| Thread Tools | |
| Display Modes | |
|
|
Similar Threads
|
||||
| Thread | Forum | |||
| 87 Par Car needs choke to start all the time | Gas Columbia ParCar | |||
| have to choke every time | Gas EZGO | |||
| Take your time and do things right the 1st time | Electric Club Car | |||
Linear Mode
