|
Electric Club Car Electric DS, and Precedent golf cars |
|
Thread Tools | Display Modes |
02-02-2012, 03:57 PM | #21 |
Not Yet Wild
Join Date: Jan 2012
Posts: 14
|
Re: 06 Club Car IQ Precedent 48 volt dead in driveway
There is only one gray wire that comes out of the of the obc. no fuses either. There is a black wire that has a disconnect. ?
|
Today | |
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
02-02-2012, 04:13 PM | #22 |
Ban Puppy Mills & Stores!
Join Date: Dec 2008
Location: SE Florida
Posts: 2,955
|
Re: 06 Club Car IQ Precedent 48 volt dead in driveway
Make sure your batteries are wired this way, that the Pos and Neg are wired correctly as well. Your Precedent Plug/OBC doesn't have a fuse like a DS does. See pictures attached.
|
02-02-2012, 04:18 PM | #23 |
Not Yet Wild
Join Date: Jan 2012
Posts: 14
|
Re: 06 Club Car IQ Precedent 48 volt dead in driveway
They are wired correctly. any suggestions?
|
02-02-2012, 04:38 PM | #24 |
Ban Puppy Mills & Stores!
Join Date: Dec 2008
Location: SE Florida
Posts: 2,955
|
Re: 06 Club Car IQ Precedent 48 volt dead in driveway
Cart isn't moving?
Wiring, controller, solenoid, motor... ?? Place in tow, remove main + and - battery leads. Remove all leads from motor making sure you have a wrench on the bottom nut as well as the top nut of terminal. (see picture attached.) You can test for continuity or resistance in the motor, A1 to A2 then F1 to F2. If open you have a problem. May I suggest purchasing a FULL manual for you cart as well. |
02-02-2012, 06:01 PM | #25 |
The Last Moja Morani
Join Date: Jan 2007
Location: jumping from cart to cart
Posts: 8,975
|
Re: 06 Club Car IQ Precedent 48 volt dead in driveway
i,m sorry the grey wire comes out of the back of the charge receptical and runs back to OBC my mistake......that grey wire has a yellow connector where theres a fuse...take it aprt right there and the peice thats connected to charge receptical run the jumper from that peies to neg of last battery...............same battery that OBC cable goes to.............................
|
02-02-2012, 07:04 PM | #26 |
Not Yet Wild
Join Date: Jan 2012
Posts: 14
|
Re: 06 Club Car IQ Precedent 48 volt dead in driveway
I took apart the black wire and jumped it to the ground. The charger will charge in that setup. I guess the OBC is bad. Does the obc control everything from there or is that for just the batteries?
|
02-02-2012, 07:17 PM | #27 |
Not Yet Wild
Join Date: Jan 2012
Posts: 14
|
Re: 06 Club Car IQ Precedent 48 volt dead in driveway
I took apart the gray from the obc and hooked to ground of last batt, charger only clicks on does not charge
|
02-02-2012, 10:15 PM | #28 |
The Last Moja Morani
Join Date: Jan 2007
Location: jumping from cart to cart
Posts: 8,975
|
Re: 06 Club Car IQ Precedent 48 volt dead in driveway
replace your OBC and cart will run and you,ll be done........................
|
02-10-2012, 03:40 PM | #29 |
Not Yet Wild
Join Date: Jan 2012
Posts: 14
|
Re: 06 Club Car IQ Precedent 48 volt dead in driveway
Hey Guys, Here is the update. I replaced the OBC today and everything seems to be fine. I'm goint to let my new trojans charge and check in the morning. Thanks again for everybodys help.
|
02-10-2012, 05:29 PM | #30 |
The Last Moja Morani
Join Date: Jan 2007
Location: jumping from cart to cart
Posts: 8,975
|
Re: 06 Club Car IQ Precedent 48 volt dead in driveway
glad to hear it.......you should be good to go now..............................
|
|
|
Similar Threads | ||||
Thread | Forum | |||
2005 club car precedent dead | Electric Club Car | |||
Dead '83? 36-volt electric club car | Electric Club Car | |||
2003 ezgo txt 36 volt is dead. | Electric EZGO | |||
05 Precedent - Dead - Charger won't come on | Electric Club Car | |||
36 volt batteries dead | Electric Club Car |