|
Electric Club Car Electric DS, and Precedent golf cars |
|
Thread Tools | Display Modes |
02-09-2012, 10:01 AM | #1 |
Not Yet Wild
Join Date: Feb 2012
Location: Newnan, Jawga
Posts: 47
|
Newbie 87 DS No Reverse
Howdy folks. Just found this site and have been doing some lurking. I've already learned a lot. I was given this cart and have replaced the batteries and bought a charger. Forward works fine, and all 5 solenoids click, but I've got no reverse.
Is there a test procedure for troubleshooting the F/R switch? Could it be lack of continuity to the reverse pole? Could I disassemble the switch and try to clean the buss bar? Also, there appears to be an aftermarket charge gauge which is hard wired. (The charge indicator light stays on even w/ key off) Is this correctly wired, and if so, will that little light drain too much current when the cart is not in use? Sorry for long 1st post and thanks in advance for anyone who can help. Matt |
Today | |
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
02-09-2012, 10:11 AM | #2 |
Happy Carting
Join Date: Dec 2007
Location: Southern California
Posts: 73,410
|
Re: Newbie 87 DS No Reverse
Welcome to bgw. Your problem could be as simple as a failed reverse micro switch, check to see the switch is properly activated and working in reverse as well as forward. If it is check the cables at the bottom lugs of the F&R. one on the passenger side supplies power for forward and the one on the drivers side (these are on the bottom of the switch) supplies power for the reverse circuit.
There is no adjustment in the CC F&R. Replacement is a good option if is worn beyond serviceable limits. With the key on, select reverse, slightly depress the peddle... do you hear the solenoids click? If yes wiggle or move the switch lever. |
02-09-2012, 10:24 AM | #3 |
Not Yet Wild
Join Date: Feb 2012
Location: Newnan, Jawga
Posts: 47
|
Re: Newbie 87 DS No Reverse
Thanks for the quick reply ScottyB. Micro on F/R appears to be working at both positions. All 5 solenoids click as you depress the pedal in forward and reverse. This cart sat in a barn for a few years, so it might be a bit corroded. I did take a small square of sandpaper and tried to clean the buss bar a little, but did not remove or disassemble the F/R. No help. Is there a test procedure to check the F/R switch? I did pull, twist and jiggle the switch while in reverse w/ pedal depressed. No help.
|
02-09-2012, 10:53 AM | #4 |
The Last Moja Morani
Join Date: Jan 2007
Location: jumping from cart to cart
Posts: 8,975
|
Re: Newbie 87 DS No Reverse
keep in mind even a clicking solenoid can be bad so its the last solenoid the one on pass. side for reverse.....you can try cleaning the buss bar and maybe just swapping a solenoid to see if reverse will work.................also check all the wires make sure you don,t have a wire broke or a bad cable end....................
|
02-09-2012, 11:02 AM | #5 |
Not Yet Wild
Join Date: Feb 2012
Location: Newnan, Jawga
Posts: 47
|
Re: Newbie 87 DS No Reverse
Thanks Shadowman. Is there a method to jump that solenoid to see it it's the problem? If so, which posts on the solenoid need to be jumpered? Can it be small gauge wire w/ alligator clips?
|
02-09-2012, 11:05 AM | #6 |
Happy Carting
Join Date: Dec 2007
Location: Southern California
Posts: 73,410
|
Re: Newbie 87 DS No Reverse
I think this system runs the same controls in F&R with the exception of the F&R rotary switch.
You might try swapping the 2 leads on the center rotary part of the switch... and see if you have only reverse now no forward? Then I think it would be safe to say you need a new F&R. What do you think, Shadowman? |
02-09-2012, 11:14 AM | #7 | |
Medicare Recipient
Join Date: Jun 2011
Location: West Michigan
Posts: 3,541
|
Re: Newbie 87 DS No Reverse
Quote:
|
|
02-09-2012, 11:36 AM | #8 | |
Happy Carting
Join Date: Dec 2007
Location: Southern California
Posts: 73,410
|
Re: Newbie 87 DS No Reverse
Quote:
Actually all drive system testing should be done on jack stands so the cart doesn't unexpectedly GO! We just fail to put the disclaimer in every thread ~ Oops! |
|
02-09-2012, 11:46 AM | #9 |
Not Yet Wild
Join Date: Feb 2012
Location: Newnan, Jawga
Posts: 47
|
Re: Newbie 87 DS No Reverse
Thanks gentlemen. I'll give that a try in a little while and report back. All the help is much appreciated.
|
02-09-2012, 11:49 AM | #10 |
The Last Moja Morani
Join Date: Jan 2007
Location: jumping from cart to cart
Posts: 8,975
|
Re: Newbie 87 DS No Reverse
scotty i agree i just wanted to point out that even a clicking solenoid can be bad.......you know me........the last one effects reverse so if f&r is ok it would have to be back there somewhere..........................
|
|
|
Similar Threads | ||||
Thread | Forum | |||
wiring a reverse light to the reverse buzzer? | Gas Yamaha | |||
Reverse won't go but if I pump gas it slams into reverse | Electric Club Car | |||
Foward in reverse and reverse in forward | Electric Club Car | |||
Reverse alarm stuck - motor won't run forward or reverse | Electric EZGO | |||
Newbie-- forward/ reverse seitch problems | Electric EZGO |