|
Gas Club Car Gas DS, and Precedent golf cars |
|
Thread Tools | Display Modes |
08-15-2016, 02:24 PM | #1 |
Not Yet Wild
Join Date: Aug 2016
Posts: 2
|
93 gas Club Car charging issues(still)
Recently got this 93 club car gas DS. I have replaced the starter generator, battery, voltage regulator, and the solenoid. I have checked the grounds and cleaned just to make sure. When I hook up the volt meter and test I am getting 12.51 to 12.60. Not enough to keep it charged. Found out that one of the micro switches was replaced but may not be the correct one, car does run after the battery is charged. Would this cause an incorrect charge? I am totally lost as to what else to do to this. Possible an outside chance that the starter gen that was a rebuild off of amazon may have not have been properly rebuilt? Any Ideas/suggestions would be great.
Thanks, |
Today | |
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
08-15-2016, 06:17 PM | #2 |
Gone Wild
Join Date: Jun 2011
Location: Northern Indiana
Posts: 2,823
|
Re: 93 gas Club Car charging issues(still)
There I a pretty good chance your "Amazon" rebuilt starter is bad. I've seen a very high failure rate even off of local, reputable shops - much less some far off unknown supplier. But before you chuck all that, check a few basics. Make sure you have battery voltage (or more) going through the white wire from the solenoid to the starter/generator while the cart is running. If yes, then disconnect the smaller yellow wire from the starter/generator and run a jumper wire to ground. That would bypass the voltage regulator and all the wires associated with it. Running the engine with the ground jumper in place should have the generator charging full tilt - something over 18 volts.
|
08-15-2016, 09:50 PM | #3 |
revolutiongolfcars.com
Join Date: Mar 2010
Location: Golf Car Capital of The World... Augusta, Georgia
Posts: 10,224
|
Re: 93 gas Club Car charging issues(still)
Don't trust the aftermarket starter/generators. Order an OEM one and you'll be glad you did. They're built to last.
|
08-15-2016, 11:03 PM | #4 |
Not Yet Wild
Join Date: Aug 2016
Posts: 2
|
Re: 93 gas Club Car charging issues(still)
Thanks for the feed back, greatly appreciated.
|
|
Thread Tools | |
Display Modes | |
|
Similar Threads | ||||
Thread | Forum | |||
Club Car DS Charging Issues | Electric Club Car | |||
08 club car charging issues-48v | Electric Club Car | |||
Club Car Charging Issues | Electric Club Car | |||
93 Club Car Charging Issues | Gas Club Car | |||
Club Car Charging issues | Electric Club Car |