|
Electric EZGO Electric EZ GO Marathon, Medalist, TXT and RXV. |
|
Thread Tools | Display Modes |
10-10-2020, 12:16 PM | #11 |
Gone Wild
Join Date: Sep 2016
Location: Northern California
Posts: 1,300
|
Re: Ezgo 36 V TXT series car with intermittent running issues
The controller is a series cart doesn’t care about f or r other than when it gets the 1/2 speed signal from the micro switch on the f/r. Your problem is not in the little wires ( the solenoid activation circuit) since the solenoid clicks and sometimes goes in f. The activation circuit doesn’t care about direction either. That leaves you with the high amp delivery system.
Have you checked all of the big cables? Nothing is corroded or loose? Pack voltage is good? Once confirming the above, I’d take the f/r apart and inspect it before just ordering a new one blindly. If you do need one, check out cartsunlimited for an hd unit. Better yet, get a reversing contactor from the same place. |
Today | |
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
10-10-2020, 03:21 PM | #12 |
Getting Wild
Join Date: Oct 2014
Posts: 80
|
Re: Ezgo 36 V TXT series car with intermittent running issues
All big cables are virtually new as I put in new batteries and cables 6 months ago. All tight and clean.
Never taken a fnr apart. Just looking for bad contacts? Sent from my iPhone using Tapatalk |
10-22-2020, 12:05 PM | #13 |
Gone Wild
Join Date: Jul 2018
Location: Ramer, AL
Posts: 1,449
|
Re: Ezgo 36 V TXT series car with intermittent running issues
Did you ever figure this out...?
|
10-23-2020, 06:21 PM | #14 |
Gone Wild
Join Date: Jun 2016
Posts: 180
|
Re: Ezgo 36 V TXT series car with intermittent running issues
I had an intermittent problem that drove me nuts till I discovered that the electric plug going into the brake was not making contact now and again...I removed the plug pushed the contacts in a little on the plug...no more problems...I have a 2009 RXV
|
|
|
Similar Threads | ||||
Thread | Forum | |||
EZGO RXV Intermittent issues - controller? Motor Brake? | Electric EZGO | |||
2004 EZGO 36v TXT Series - Intermittent Stop and Go | Electric EZGO | |||
Intermittent / temporary running EZGO | Electric EZGO | |||
EZGO TXT Intermittent running | Electric EZGO | |||
2009 gas ezgo - intermittent running problems | Gas EZGO |