|
Gas Club Car Gas DS, and Precedent golf cars |
|
Thread Tools | Display Modes |
03-03-2018, 09:41 PM | #1 |
Getting Wild
Join Date: Jan 2014
Posts: 119
|
Key start club car gas won't go forward or reverse
I have a key start club car gas model. 2004. My starter generator was giving me trouble. I replaced it after getting tired of the hammer method. After replacing it, the cart wouldn't start. Solenoid just clicks. I jumped the solenoid off the two big posts to test it and it started. Odd thing is it wouldn't move in forward or reverse while jumping the solenoid. I thought maybe a short / bad solenoid. I replaced it, now it will idle as usual, but still won't move in forward or reverse. Also would not shut off when I turned the key off. Had to remove battery cable to kill the cart. Any suggestions?
|
Today | |
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
03-12-2018, 02:04 PM | #2 |
Gone Wild
Join Date: May 2011
Posts: 195
|
Re: Key start club car gas won't go forward or reverse
Is it in maintenance mode? Battery fully charged? Micro switches connected properly?
Recheck your wiring when you changed the solenoid and the starter. |
03-13-2018, 02:35 PM | #3 |
Getting Wild
Join Date: Jan 2014
Posts: 119
|
Re: Key start club car gas won't go forward or reverse
Yes, all that is fine. New solenoid today, now it starts and shuts down correctly with the key. Still will not move forward or reverse. I checked the coil and I do have spark. I also cleaned the carb so its good as well. The small belt on the SG is spinning, but the clutch belt is not doing anything. I don't see the shiny shaft(under the spring) spining behind the big clutch wheel.
Any ideas on where to from here? Thanks |
03-13-2018, 02:46 PM | #4 |
Getting Wild
Join Date: Nov 2016
Location: michigan/georgia
Posts: 133
|
Re: Key start club car gas won't go forward or reverse
if the clutch turns the cart sould move shift cable broke? put in gear by hand then start only way the motor runs and not go is trans stuck between gears,has happened or shift lever key sheared,not shifting.
|
03-16-2018, 09:39 AM | #5 |
Getting Wild
Join Date: Jan 2014
Posts: 119
|
Re: Key start club car gas won't go forward or reverse
No the clutch is not turning. Shift cable is good. I checked that first. The only way to see if key is sheered is by taking off wheel and then clutch wheel?
|
03-16-2018, 12:14 PM | #6 |
Gone Wild
Join Date: Dec 2017
Location: Portsmouth, VA
Posts: 626
|
Re: Key start club car gas won't go forward or reverse
if engine is spinning and Drive Clutch is NOT, maybe the key. you should be able to see the engine shaft spinning. also is the entire CLUTCH not spinning ??
|
03-16-2018, 02:16 PM | #7 |
Getting Wild
Join Date: Jan 2014
Posts: 119
|
Re: Key start club car gas won't go forward or reverse
Nope, entire clutch not spinning.
|
03-16-2018, 02:35 PM | #8 |
Gone Wild
Join Date: Dec 2017
Location: Portsmouth, VA
Posts: 626
|
Re: Key start club car gas won't go forward or reverse
well if engine shaft is spinning and clutch is not, really sounds like the key.
should be easy to get the clutch assembly off, bc it should not be stuck on the shaft. remove belt and clutch should slide right off ?? |
03-17-2018, 03:50 AM | #9 |
What the ....?
Join Date: Jan 2007
Location: N.E. Wisconsin
Posts: 14,930
|
Re: Key start club car gas won't go forward or reverse
Let's take a couple of steps back here!
For clarification... Drive Clutch = Front... mounted on the engine. (also considered a "Primary" clutch) Driven Clutch = Rear... mounted on the transaxle. (also considered a "Secondary" clutch) This is what I'm getting out of this... You have a 2004 key start cart, You've replaced the Starter/Generator, it starts and idles, BUT... the (rear) DRIVEN clutch isn't turning! So this brings up a question, and a suggestion... When the engine starts and idles... does the engine rev up higher than just an idle? If not... the S/G is probably just cranking the engine over, and it's not actually running or idling. To follow up with mrlmd's suggestion about checking the wiring... Since you've replaced the S/G, double check the engine rotation while it's cranking over.
If the engine starts, idles, AND... revs up? Then, it's something completely different! |
03-18-2018, 01:25 PM | #10 |
Getting Wild
Join Date: Jan 2014
Posts: 119
|
Re: Key start club car gas won't go forward or reverse
Thank you for the info. It is spinning counter clockwise. The confusion is there's only one way to wire up the SG. I wired it up the same as the other. The only difference is the white wire that hooks up on the top of the SG, is placed on the very front of the it , the white wire barely reached. I really had to stretch and use every bit of slack it had to connect.
Is this the wrong SG for the cart? It's a Nidec drive systems.12 bolt. part # 114-04-4004. I got it from a big online cart store, not a cheap SG. |
Tags |
club car gas key start |
|
|
Similar Threads | ||||
Thread | Forum | |||
Jerky forward and reverse start | Electric EZGO | |||
Starts in reverse' cranks but no start in forward | Gas Yamaha | |||
Ezgo marathon will start in reverse but not in forward | Gas EZGO | |||
'97 G16E Jerk Start Forward and Reverse | Electric Yamaha | |||
fires right up in reverse but want start in forward | Gas EZGO |