07-02-2019, 11:04 AM | #1 |
Not Yet Wild
Join Date: Jun 2019
Posts: 6
|
Jerky start 1997 CC Gas
I apologize in advance but I couldn't find using the search tools, plus I'm new to Buggies. Recently purchased a clean 1997 CC gas DS, however when I hit the gas pedal in either F or R there is no slow start. It jerks once hard then runs great. I believe that the previous owner adjusted the governor to increase speed b/c I am at 15MPH. I am going to slow the governor back down to about 11MPH. My 2001 CC gas engine starts as I hit the gas but does not move until I engage further. My 2001 seems right. Any suggestions on the "once jerk" on the 1997? Thank you all in advance.
|
Today | |
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
07-02-2019, 02:43 PM | #2 |
Gone Wild
Join Date: Dec 2017
Location: Portsmouth, VA
Posts: 626
|
Re: Jerky start 1997 CC Gas
sounds like the pedal rod was adjusted so that once you touch the pedal it engages. check the pedal linkage rod and the adjustment inside hte black box, sure they tweaked it to the max to get the few mph out.
if you look at the stickie Speeding up your Club Car and jsut do it in reverse |
07-02-2019, 03:40 PM | #3 |
Gone Wild
Join Date: Dec 2009
Location: Aiken, SC
Posts: 13,146
|
Re: Jerky start 1997 CC Gas
Yep need a little slack in there. If not too tight then they may have the idle setting to far in. With the key off so the cart won't start, hit the go pedal and see when the throttle linkage on top of the carb moves. If it moves as soon as you touch the pedal the linkage is too tight. If the pedal travels some before it moves the idle is probably in too far..
|
07-02-2019, 10:01 PM | #4 |
Not Yet Wild
Join Date: Jun 2019
Posts: 6
|
Re: Jerky start 1997 CC Gas
Thank you both so much. Adjusted the pedal rod inside the box and all is well.
|
07-02-2019, 10:45 PM | #5 |
Gone Wild
Join Date: Dec 2009
Location: Aiken, SC
Posts: 13,146
|
Re: Jerky start 1997 CC Gas
You are welcome from a fellow Kris
|
Tags |
drive clutch, hard start, jerk |
|
|
Similar Threads | ||||
Thread | Forum | |||
Jerky start??? | Electric EZGO | |||
Jerky Start, Jerky Stop | Electric Club Car | |||
Jerky start | Gas Yamaha | |||
Jerky start | Gas EZGO | |||
Jerky Start | Electric Club Car |