12-04-2016, 01:54 PM | #1 |
Not Yet Wild
Join Date: Dec 2016
Location: Nebraska
Posts: 18
|
36v 4 wheel Columbia SN tag not found
Just bought this Columbia 4 wheel 36v cart and seller said it was 1983 model. Checked locations the SN is supposed to be and looked all under this thing but can't find any SN tag at all.
Weird also that the 5 relay configuration doesn't match the solenoid arrangement-quick ref guide (closest to the DE, DEC with 2 then 3 below). My solenoid arrangement is two, then two directly below them then fifth off to right and slightly below the second set like this: X X X X -------> X Wanted SN so as to double check the heavy wires as previous owner may not have them hooked up correctly. |
Today | |
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
12-04-2016, 03:09 PM | #2 |
Guest
Posts: n/a
|
Re: 36v 4 wheel Columbia SN tag not found
what are the volts of the solenoid ?
sounds like a 71 |
12-04-2016, 03:46 PM | #3 |
Not Yet Wild
Join Date: Dec 2016
Location: Nebraska
Posts: 18
|
Re: 36v 4 wheel Columbia SN tag not found
12v 12v
12v 12v ...............12v? (too rusty to tell) |
12-04-2016, 04:13 PM | #4 |
Not Yet Wild
Join Date: Dec 2016
Location: Nebraska
Posts: 18
|
Re: 36v 4 wheel Columbia SN tag not found
I uploaded a few pics in my CP public page (won't let me post new member links for 7 days).
|
12-04-2016, 05:04 PM | #5 |
Guest
Posts: n/a
|
Re: 36v 4 wheel Columbia SN tag not found
|
12-04-2016, 05:07 PM | #6 |
Not Yet Wild
Join Date: Dec 2016
Location: Nebraska
Posts: 18
|
Re: 36v 4 wheel Columbia SN tag not found
lol...control panel. Better to have said my profile page.
|
12-04-2016, 06:00 PM | #7 | |
Guest
Posts: n/a
|
Re: 36v 4 wheel Columbia SN tag not found
Quote:
1982 wiring |
|
12-04-2016, 07:52 PM | #8 |
Not Yet Wild
Join Date: Dec 2016
Location: Nebraska
Posts: 18
|
Re: 36v 4 wheel Columbia SN tag not found
I see where looks like SN plate may have been there but long since gone. Not too concerned but just needed some assurance I was following the proper schematic.
Used the schematic you referenced above and believe I had a battery bank ground swapped but all seems well now. Thank you CTD! |
12-04-2016, 10:56 PM | #9 |
Guest
Posts: n/a
|
Re: 36v 4 wheel Columbia SN tag not found
|
12-04-2018, 09:56 PM | #10 |
Not Yet Wild
Join Date: Dec 2016
Location: Nebraska
Posts: 18
|
Re: 36v 4 wheel Columbia SN tag not found
Wierd thing is none of the schematics or the solenoid charts exactly match this thing.
Would any of these help give year away? * Says "columbia" on back bumper and steering wheel. * Motor is a direct drive * Have 5 solenoids top two being 6 post (12v now but may have been 6v originally) similar one in solenoid ID chart except top two of mine are 6 post. * Delay tube is two wire-red and blk * Switch is 4 wire (Red Yel Blue Grn) * Battery arrangement is all six in front like shown in pic above. * Just 1 resistor coil * 4 wheel |
|
|
Similar Threads | ||||
Thread | Forum | |||
Harley Davidson Columbia 4 wheel Golf Cart | Gas Harley Davidson | |||
1987 Columbia ParCar 4-Wheel Gas DX4 cranks but won't run - Flooding? | Columbia ParCar | |||
1988 Four Wheel Gas Columbia | Gas Columbia ParCar | |||
Lugnut, stud, rear wheel problem (wheel came off) | Lifted Golf Carts | |||
Rear Wheel Studs too Short for 3 inch wheel Spacer | Electric EZGO |