|
Gas Club Car Gas DS, and Precedent golf cars |
|
Thread Tools | Display Modes |
12-20-2011, 11:36 PM | #1 |
Not Yet Wild
Join Date: Dec 2011
Location: Phoenix area
Posts: 16
|
2002 club car oil light comes on at top end
I just picked up a very nice 2002 club car with Stretch Plastics 6" lift with long travel and 22" Duro tires. The thing runs great. I took it out tonight (just picked it up last night) and GPS speed indicates 21-22 mph on flat pavement. I did a little checking and I think the ground cable for the rev limiter has been disconnected already. There does not seem to be a modification to the govenor. When I am at about 20 mph or more the oil light comes on, does not seem to be consistent but it does come on. Runs smooth, no cutting out, etc. Thing has been consistently maintained. I sent a question to the previous owner but it may be a day or two before I hear back. Any thoughts or suggestions? thanks, Dave
|
Today | |
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
12-20-2011, 11:48 PM | #2 |
Not Yet Wild
Join Date: Dec 2011
Location: Phoenix area
Posts: 16
|
Re: 2002 club car oil light comes on at top end
OK, got an answer very quickly from the previous owner, anyway, he stated that he has 20w-50 in it due to us being in Phoenix and the extreme heat we have here, and not to push it for the first 1/4-1/2 mile until the oil has a chance to thin out then it should be fine, makes sense.
I will post some photos of the cart when I get a chance, this thing is a real hoot to drive and the stretch plastics lift and long travel is a great ride. can't believe this thing is doing 20-22 mph, has a tach and the RPMs so far do not seem to go above 2600, Dave |
12-21-2011, 08:18 AM | #3 |
The Last Moja Morani
Join Date: Jan 2007
Location: jumping from cart to cart
Posts: 8,975
|
Re: 2002 club car oil light comes on at top end
if you change the oil keep in mind the lift is gonna thtrow the oil dipstick off......when you put 40 ozs in and check it will indicate its not full and then you,ll overfill it.................if it hasn,t been done you might want to make a new full mark on the dipstick.................................
|
12-21-2011, 09:21 AM | #4 |
Not Yet Wild
Join Date: Dec 2011
Location: Phoenix area
Posts: 16
|
Re: 2002 club car oil light comes on at top end
Thx! I'll make note and when I change it I will indicate a new mark. Dave
|
12-21-2011, 11:30 AM | #5 |
Not Yet Wild
Join Date: Dec 2011
Location: Phoenix area
Posts: 16
|
Re: 2002 club car oil light comes on at top end
OK, here's some photo's of my new buggie! hope the attachments work,,,
|
12-21-2011, 12:41 PM | #6 |
The Last Moja Morani
Join Date: Jan 2007
Location: jumping from cart to cart
Posts: 8,975
|
Re: 2002 club car oil light comes on at top end
yep they worked......the only thing i don,t like is the way the brushguard leans way forward.......looks a bit odd but other than that cart looks good..............................
|
12-22-2011, 04:00 PM | #7 |
Not Yet Wild
Join Date: Dec 2011
Location: Phoenix area
Posts: 16
|
Re: 2002 club car oil light comes on at top end
Yes it does, but boy they sure ride nice!
|
12-26-2011, 10:34 AM | #8 |
Gone Wild
Join Date: Jan 2007
Location: La Porte Indiana
Posts: 1,392
|
Re: 2002 club car oil light comes on at top end
another thing that helps is going to synthetic oil. i don't have exp. in the heat out there.. but i know in the cold it flows a lot quicker for me. the oil light comes on when the pump empties the crankcase and it isn't flowing back quick enough.
btw nice cart! |
12-26-2011, 10:47 AM | #9 |
Not Yet Wild
Join Date: Dec 2011
Location: Phoenix area
Posts: 16
|
Re: 2002 club car oil light comes on at top end
Thanks!!! I jacked it up to get the motor level again the other day, drained the oil out and emptied the filter. Then measured 37 oz of oil and put in the engine. the level was right at the "FULL" mark, then lowered it back down, and the oil was at the "ADD" mark now, so the add mark is now where the oil level should be. I did use 10w-30 synthetic oil and no more light problems! It had to much oil for sure. Someone else told that when there is to much oil, the slinger really causes a ripple effect in the oil level making the sensor think the level is low when there is actually to much oil. I think there was probably about 1/4-1/2 qt to much oil, I was getting some blue smoke at top end also,,,,no more smoke either! adjusted the governor a little and no revlimiter so it gets to about 25 mph with just me. Have to install my 200 rpm spring in the clutch, it already has the driven clutch spring in and I need to have the driven clutch machined. Also want to put some seat belts on for the grand kids! Dave
|
|
|
Similar Threads | ||||
Thread | Forum | |||
2002 Club Car DS IQ 48V | Electric Club Car | |||
2002 Club | Electric Club Car | |||
wiring LHT EZ1 2002 light kit from Buggies Unlimited? | Electric EZGO | |||
Wanted Front driver side light kit for EZGO 2002 | Golf Carts and Parts |