06-09-2008, 07:33 PM | #1 |
Not Yet Wild
Join Date: Jun 2008
Posts: 3
|
92 Club Car Starting
I have a 92 Club Car, it was running great today and then it would not go forward or back. No noise from engine either. I tapped the solenoid and I can get a click from it but the cart won't go, sometimes it will hum for a bit but then stop. I am planning on getting a new solenoid tom. but want to get your input on the fact that I am doing the right thing. Thanks for your help.
|
Today | |
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
06-10-2008, 08:42 AM | #2 |
Getting Wild
Join Date: Mar 2008
Posts: 90
|
Re: 92 Club Car Starting
Check to see if the brushes in your starter/gen are bad. Turn the clutch
about a half turn by hand and see if it starts. Also, make sure your battery is OK.. |
06-10-2008, 01:08 PM | #3 |
Not Yet Wild
Join Date: Jun 2008
Posts: 3
|
Re: 92 Club Car Starting
Thanks for your help. I was told today not to get the solenoid as it did not sound like that might be the problem. Like you said, I was told to check the battery, which I have on charge now but looking at it I think I will get a new one this afternoon anyway. Excuse my ignorance but where will I locate the "brushes" and how will I know if they are bad.
Thanks again |
06-10-2008, 02:33 PM | #4 |
Getting Wild
Join Date: Mar 2008
Posts: 90
|
Re: 92 Club Car Starting
Starter/Gen brushes are under the little black rubber plugs on one end
of the starter. There is a spring that holds each one down to the armature. When these wear too much, one won't make contact, therefore rotate your clutch by hand a half turn and most of the time it will start. Remember this if you are ever out on the back side of nowhere , and the starter won't turn. That humming of the solenoid is crying "Battery" to me. |
06-10-2008, 06:17 PM | #5 |
Not Yet Wild
Join Date: Jun 2008
Posts: 3
|
Re: 92 Club Car Starting
thanks for the advice. I got the new battery and so far, so good. I may try to attempt to check the brushes but as they say don't try and fix something that is not broken. Thanks again
|
11-11-2010, 04:29 PM | #6 |
Not Yet Wild
Join Date: Jan 2010
Location: Baton Rouge, Louisiana
Posts: 17
|
Re: 92 Club Car Starting
Can someone give me step by step instructions on how to start a 1992 gas Club Car. I just got it and don't have a clue.
|
11-12-2010, 03:19 PM | #7 | |
What the ....?
Join Date: Jan 2007
Location: N.E. Wisconsin
Posts: 14,933
|
Re: 92 Club Car Starting
Quote:
|
|
Tags |
solenoid |
|
|
Similar Threads | ||||
Thread | Forum | |||
82 G1 starting to clunk | Gas Yamaha | |||
Hard starting 98 w/ 295 | Gas EZGO | |||
Starting a Resto. | Gas Club Car | |||
Starting a new project | Gas Yamaha | |||
91 ez-go starting problems | Gas EZGO |