Gets No Gas

wolenik · 06-13-2018, 08:41 PM

'92 club car. New hoses, fuel pump, carb is clean. Turns over but won't start. Spray starter fluid into intake and runs for a few seconds. Carb float bowl is full of gas. Jets blow clean. Real mystery.

jdgriner · 06-13-2018, 11:31 PM

Even though you found gas in the carb, I would still check the very basics.

Pull the fuel line from the inlet to the carb, step on the pedal see if gas pulses from the fuel line.

New hoses.... make sure there's no drupes in The pulse Line going to the fuel pump, if there is a drupe in that line the line will fill up with oil and will quit pulsing.

Spray starter on the outside of the carb, if the engine takes off and runs then you know you have a gasket leak at the carb.

Sent from my Nexus 6P using Tapatalk

06-13-2018, 08:41 PM	#1
wolenik Not Yet Wild Join Date: Jul 2017 Posts: 4	Gets No Gas '92 club car. New hoses, fuel pump, carb is clean. Turns over but won't start. Spray starter fluid into intake and runs for a few seconds. Carb float bowl is full of gas. Jets blow clean. Real mystery.
wolenik Not Yet Wild Join Date: Jul 2017 Posts: 4

06-13-2018, 11:31 PM	#2
jdgriner Getting Wild Join Date: May 2017 Location: stl mo Posts: 113	Re: Gets No Gas Even though you found gas in the carb, I would still check the very basics. Pull the fuel line from the inlet to the carb, step on the pedal see if gas pulses from the fuel line. New hoses.... make sure there's no drupes in The pulse Line going to the fuel pump, if there is a drupe in that line the line will fill up with oil and will quit pulsing. Spray starter on the outside of the carb, if the engine takes off and runs then you know you have a gasket leak at the carb. Sent from my Nexus 6P using Tapatalk

Today
BGW	Sponsored Links __________________ This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum