08-30-2017, 11:48 AM | #1 |
Getting Wild
Join Date: May 2017
Posts: 115
|
1986 EZGO sluggish
New to the Cart world and just picked up an 86 EZGO to tinker with over the winter.
Problem is the cart is sluggish to start in forward and seems faster in reverse. Once it gets going the cart runs good but will lose fuel pressure after running for about a 1/2 hour. I stripped down and cleaned carb and replaced fuel filters. Any help is appreciated!!! |
Today | |
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
08-30-2017, 09:04 PM | #2 |
Getting Wild
Join Date: May 2016
Posts: 122
|
Re: 1986 EZGO sluggish
Usually faster in reverse means the crank seals are worn.
|
08-31-2017, 09:57 AM | #3 |
Hammer Down !!!!
Join Date: Jun 2010
Location: Lake Geneva, WI
Posts: 2,681
|
Re: 1986 EZGO sluggish
I agree with the crank seals, if they're going bad it's also common for them to act worse when the engine heats up, which will cause a loss in crankcase pressure and ensuingly, lower fuel pressure.
|
08-31-2017, 11:36 AM | #4 |
Not Yet Wild
Join Date: Jul 2017
Posts: 71
|
Re: 1986 EZGO sluggish
just for reference: I also purchased an 86 gas ezgo a few months ago.
Have you checked your compression? Also, reach down and grab the drive clutch that is attached to the motor shaft. Can you wiggle it? Is there play in the motor shaft. If so that would indicate worn crankshaft or seals. My motor had 60lbs of compression where normal should be around 130lb. I ended up installing a new top end kit on mine for about $300. This kit came with new cylinder jug, piston/rings, gaskets, crankshaft, piston arm, crankshaft and piston bearings. I also paid my local ezgo dealer $70 to crack my case and install the crankshaft. Now my compression is around 125lb. |
09-06-2017, 11:01 AM | #5 |
Getting Wild
Join Date: May 2017
Posts: 115
|
Re: 1986 EZGO sluggish
Thanks for all the replies. Cart is up at the summer house and will check the Crank seals and compression this weekend..
|
|
|
Similar Threads | ||||
Thread | Forum | |||
Sluggish starter 89 Ezgo Marathon | Gas EZGO | |||
Sluggish Gas 2003 EZGO | Gas EZGO | |||
98 electric ezgo sluggish up hills | Electric EZGO | |||
sluggish 88 ezgo | Gas EZGO | |||
EZGO or Yamaha? Upgrading from EZGO Series sluggish cart | Electric Yamaha |