lifted club cars - lifted ezgo
Home FAQDonate Who's Online
Go Back   Buggies Gone Wild Golf Cart Forum > Golf Cart Repair and Troubleshooting > Electric golf carts > Columbia ParCar


Post New Thread  Reply
 
Thread Tools Display Modes
Old 08-17-2014, 09:11 PM   #1
robert mack
Not Yet Wild
 
Join Date: Aug 2014
Posts: 3
Default 2010 parcar smt4-tn

vin# 5fcls46b9a1001611
I would like a service and parts manual for this unit. Do you have a web site that I could down load one along with wire diagram ?

I just purchased one that the Gov had. I was told it would run 30mph. It runs
11mph flat road on high and low mode. Batteries are full charge. Any help would be greatfull.

Also could you tell me if there is any campaigns due by this vin# ?

Thanks for any help

Bob
robert mack is offline   Reply With Quote
Alt Today
BGW

Golf car forum Sponsored Links

__________________
This advertising will not be shown in this way to registered members.
Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum
   
Old 08-18-2014, 08:28 AM   #2
Tech Support
How Can I Help?
 
Tech Support's Avatar
 
Join Date: Oct 2009
Location: SW Wisc & West Central, FL
Posts: 1,386
Default Re: 2010 parcar smt4-tn

The speed issue is most likely the speed encoder on the end of the motor. When it fails, the unit defaults to roughly half speed. That means what used to be 100% of max in forward goes to 50% and what used to be 30% of max in reverse also goes to 50%. The non-technical test is if both forward and reverse are now approximately the same speed, the encoder (or the connector) is bad. It's held on with just two small screws and you don't need to remove the motor to replace it. (Part is 74884-04)

The unit had a recall on the steering, and it was replaced in 2011. There were no other warranty claims for it.

Top speed by federal law is limited to 25mph, but yes, sometimes depending on terrain they all can vary a bit.
Tech Support is offline   Reply With Quote
Old 08-18-2014, 12:07 PM   #3
robert mack
Not Yet Wild
 
Join Date: Aug 2014
Posts: 3
Default Re: 2010 parcar smt4-tn

Can I test the encoder with my multimeter to see if it is bad ? Can I replace it without doing any calibration?

Thankyou for checking on the campaigns for me.

Is there a web site I can go to for download a service and parts manual for this unit?

Thanks again for your help.

Bob
robert mack is offline   Reply With Quote
Old 08-18-2014, 12:09 PM   #4
Tech Support
How Can I Help?
 
Tech Support's Avatar
 
Join Date: Oct 2009
Location: SW Wisc & West Central, FL
Posts: 1,386
Default Re: 2010 parcar smt4-tn

Can't testing, but after replacement, no calibration or adjustment necessary.

The manuals for newer vehicles are not on website outside of dealer portals. Make a couple more posts so I can pm you.
Tech Support is offline   Reply With Quote
Old 08-18-2014, 07:06 PM   #5
robert mack
Not Yet Wild
 
Join Date: Aug 2014
Posts: 3
Default Re: 2010 parcar smt4-tn

I am going to look behind the dash panel to make sure a wire did not come off the switch.

It has 12" wheel steel trailer type, Where is a good place to get a spare
rim with tire at a reasonable price?

So you think only place to get service and parts manual would be to buy from dealer ? And Electric diagram also ?

Thanks again for the help you have given me.
robert mack is offline   Reply With Quote
Reply
Go Back   Buggies Gone Wild Golf Cart Forum > Golf Cart Repair and Troubleshooting > Electric golf carts > Columbia ParCar


Thread Tools
Display Modes


Similar Threads
Thread Forum
2010 ParCar will not switch to fast mode Columbia ParCar
parcar won't go Columbia ParCar
Parcar Golf Carts and Parts
87 parcar Gas Columbia ParCar


All times are GMT -5. The time now is 09:11 AM.


Club Car Electric | EZGO Electric | Lifted Golf Carts | Gas EZGO | Used Golf Carts and Parts

Powered by vBulletin® Version 3.8.9
Copyright ©2000 - 2024, vBulletin Solutions, Inc.
This Website and forum is the property of Buggiesgonewild.com. No material may be taken or duplicated in part or full without prior written consent of the owners of buggiesgonewild.com. 2006-2017 Buggiesgonewild.com. All rights reserved.