07-20-2011, 07:24 PM | #1 |
Not Yet Wild
Join Date: Apr 2011
Posts: 12
|
94 CC help
I replaced the spark plug and filters.
Cart will turn over with pedal pushed but not start. It will only start if you pump the gas or shoot it with carb cleaner. Any Ideas on the limited info. |
Today | |
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
07-20-2011, 07:58 PM | #2 |
The Last Moja Morani
Join Date: Jan 2007
Location: jumping from cart to cart
Posts: 8,975
|
Re: 94 CC help
sounds like you have a fuel issue...........pull the fuel line right at carb and put cart in maintence mode crank it over see if its pumping fuel to carb if so you have a carb problem...............if not than a fuel pump problem......both can be cleaned just need to be careful and take yoyr time do it right..........otherwise its a waste of time..............................
|
07-20-2011, 08:12 PM | #3 |
Gone Crazy
Join Date: Jan 2007
Location: Chesterfield, Va
Posts: 6,021
|
Re: 94 CC help
More history?
Has it been sitting? Try to start it and then remove plug, is it wet? Follow Toms direction with the fuel line flow test. If it is pumping out of the hose you need to remove the carb and check the bowl for dirt/trash, if you find dirt clean the carb and jets, fuel lines, and check fuel tank, do it once from carb to tank 100% or it will happen again. If it is not pumping first check the pulse line from the pump to engine block for cracks or plugged, then the pick up tube and lines from tank to pump. Then if all that is good clean fuel pump. |
07-26-2011, 08:43 PM | #4 |
Not Yet Wild
Join Date: Apr 2011
Posts: 12
|
Re: 94 CC help
It hasnt been sitting. I checked the fuel pump and it pumps like crazy. The carb just sits there and leaks gas from the bottom drain valve
|
07-26-2011, 09:20 PM | #5 |
The Last Moja Morani
Join Date: Jan 2007
Location: jumping from cart to cart
Posts: 8,975
|
Re: 94 CC help
you,ll need to take the carb off and find out whats going on with it........................
|
07-27-2011, 06:52 AM | #6 |
Gone Wild
Join Date: Apr 2010
Location: West Tennessee
Posts: 1,269
|
Re: 94 CC help
Known as the overflow, becasue the needle is stuck and cannot shut off the supply. You need to pull carb and clean and inspect. Our GO GREEN FUEL we get now is stopping up more carbs.
|