94 club car wont go f/R

[chasman8181]

I have a 1994 36v club car that won't go f/r. I have replaced the solenoid and still nothing, if I jack up the rearend and put the cart in forward the rear wheels turn at full throttle but as soon as I press the pedal it stops. It does not do this in reverse. I have replaced the solenoid and the v slide wiper and still no change. The batteries are showing 5.9-6.0 on the volt meter. Any suggestions would be very helpful. Thanks

[Sergio]

Other than your batteries are shot (6v is less than 50% SOC), you have the micro-switch in the VGlide wired wrong.

Make sure You are using the NC (Normaly Closed) contacts on the pedal micro-switch.

[chasman8181]

Thanks for the reply, how many volts does a charged 6 v battery carry? All 6 of my batteries show 6v.I tried the mc wiring and nothing changed. As for the foot pedal mc I can't seem to be able to locate it, I thought it was under the cart. Where else could it be?

[scottyb]

The throttle V glide is a black pie shaped device mounted on & above the frame rail under the drivers seat

36v resistor or solid state drive?

[Sergio]

As scottyb said, it is inside the Pie shaped box, referred to as "Speed box", top left of the wiring diagram below:

http://www.buggiesgonewild.com/attac...ire_vglide.jpg

[chasman8181]

Thanks guys for the advice, it was the micro switch in the v glide. I jumped it and presto it worked. Ordered a new one today, should be up and running Friday!!