|
Gas Yamaha Gas Yamaha Golf Cars; G1 through "The Drive" and U-Max Utility Vehicles |
|
Thread Tools | Display Modes |
03-22-2012, 11:08 AM | #1 |
Not Yet Wild
Join Date: Jan 2012
Posts: 8
|
g 16 high speed jet kit
i was wondering if anyone has put a jet kit in or does it help with performance? i have a 96 g16 with lift 22" tires just wanting to go a little faster thanks
|
Today | |
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
03-22-2012, 07:36 PM | #2 |
Gone Wild
Join Date: May 2011
Location: North East Tn.
Posts: 1,029
|
Re: g 16 high speed jet kit
I have a g-20 same as a 16 with a plowmans free flow air filter, jet kit and rear clutch with there black spring and belt. I just done the Governor thing where you drill the top of the bracket and have 23" tires. My cart's weight is 1000 lbs and with me and a friend about 480 lbs top speed by GPS was 32/34 mph, 28/30 without running its guts out!!!!
Hope this helps,LURCH!!!!! |
03-22-2012, 07:46 PM | #3 |
Not Yet Wild
Join Date: Jan 2012
Posts: 8
|
Re: g 16 high speed jet kit
thanks lurch just ordered jet kit and the white spring. I gps it at 26 didnt really want to drill the gov out yet my kids ride it
|
03-23-2012, 09:08 AM | #4 |
Vegas modded 420
Join Date: Jun 2009
Location: West MI
Posts: 15,445
|
Re: g 16 high speed jet kit
I would make sure your belt was not worn and if you have the tension cable on the engine set that right. I tightened it (better take off up a hill) until I lost top speed (hand held gps) then backed it off a little. Air the rear tires up a little more I run 12-15psi but also haul loads in my box. Governor will control speed because you need rpm to get speed. I don't know if the jet helps that much I hogged the airbox out on my G9 and then had to enlarge the jet quite a bit, but racing another cart it didn't make much difference...maybe but hard to tell. IMO making sure the clutches are tip top shape (cleaned lubed working well) gives more results than engine mods. A cut secondary sheave will help takeoff and towing but does not affect higher speeds. The clutch springs help but I've not run one, but again they help power mostly too big a spring will hurt top speed so make sure you get the right one. I would say plowmans knows what he is doing watch out if you get an ebay spring/etc. My g9 with no limiter will run 30gps on pavement and 28 on dirt (on the level), on 22s, stock spring that was stretched a little.
|
|
|
Similar Threads | ||||
Thread | Forum | |||
D&D PDS High Speed Motor and 8:1 High Speed Gear Experiment... | Electric EZGO | |||
Switching from High speed to Low Speed | Electric Club Car | |||
high speed gears with emp 2 speed, advice please | Electric EZGO | |||
new high speed motor and still no speed | Electric EZGO | |||
1985 G1 Runs fine low speed , high speed run for a mile then fall on its face | Gas Yamaha |