11-09-2015, 12:38 PM | #11 |
Not Yet Wild
Join Date: Nov 2015
Location: Omaha, NE
Posts: 18
|
Re: 1985 EZGO No Power
I haven't had it back together to gps the speed yet "cart around" Yesterday I changed all the filters, replaced the fuel lines, replaced the spark plug (I found out when I replaced the plug that it had the wrong one in it that was almost twice as long as it should have been) Pulled off the driven clutch (slid right off when I took off the retaining bolt. No extra tool needed :) ) Everything looked good on the clutch, no broken spring, ramp buttons looked good too. And BBQ'd the muffler. Will put that back on when I get home from work and see what happens.
|
Today | |
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
11-09-2015, 12:58 PM | #12 |
Not Yet Wild
Join Date: Jun 2009
Location: Washington
Posts: 57
|
Re: 1985 EZGO No Power
I wonder if the clutch could have been slipping on the shaft? I've never had any come right off..
|
11-09-2015, 01:28 PM | #13 |
Not Yet Wild
Join Date: Nov 2015
Location: Omaha, NE
Posts: 18
|
Re: 1985 EZGO No Power
I never thought of that. When I turn it by hand it turns the wheels though.
|
11-09-2015, 06:31 PM | #14 |
Gone Wild
Join Date: Sep 2012
Posts: 214
|
I get 22 mph on stock tires... Have to GPS it again on the current 22's.
Sent from my XT1254 using Tapatalk |
11-09-2015, 06:44 PM | #15 |
Not Yet Wild
Join Date: Jun 2009
Location: Washington
Posts: 57
|
Re: 1985 EZGO No Power
|
11-30-2015, 08:36 PM | #16 |
Professional jerry rigger
Join Date: May 2012
Location: illinois
Posts: 337
|
Re: 1985 EZGO No Power
|
12-17-2015, 03:00 PM | #17 |
Not Yet Wild
Join Date: Nov 2015
Location: Omaha, NE
Posts: 18
|
Re: 1985 EZGO No Power
I put it in the shed for the winter. It's a 2 stroke and I don't remember a key way. It's put to bed until spring when I can get the garage back from the wife.
|
12-17-2015, 05:25 PM | #18 |
Gone Wild
Join Date: Feb 2011
Posts: 1,515
|
Re: 1985 EZGO No Power
No your correct !!! it is a spline shaft and if it slid off (Good For You) I've had some to be a bear and some to be nice like yours. When you get ready to install it be sure to replace the seal also. YES there is a rear end seal.
LOU |
04-23-2016, 04:04 PM | #19 |
Not Yet Wild
Join Date: Nov 2015
Location: Omaha, NE
Posts: 18
|
Re: 1985 EZGO No Power
Finally got it back out. On a slight down slope but mostly flat surface it topped out at 17 but where it was level it only got to about 15.
|
|
|
Similar Threads | ||||
Thread | Forum | |||
1985 club car no power going up hill | Electric Club Car | |||
1985 ezgo has no power | Gas EZGO | |||
Need help for 1985 ezgo 36v | Electric EZGO | |||
1985 ezgo electric 36v FNR switch controls power | Gas EZGO |