09-09-2011, 06:33 PM | #1 |
Not Yet Wild
Join Date: Aug 2011
Location: La Junta Colorado
Posts: 7
|
Carb replacement
I have a 85 EZ Go GX series cart with the Robin 244 cc engine. I can't seem to get the float level set. It is either too high and floods or is too low and won't allow fuel into the carb. Is there a replacement carb that would work.
By the way, I have disabled the oil injection system as the pump is no good and am now mixing oil in the fuel. I don't know if this is part of the problem. Any help would be appreciated. Thanks, Cartnovice |
Today | |
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
09-09-2011, 08:51 PM | #2 |
Respect the Cart
Join Date: May 2010
Location: Rocky Mount, Virginia
Posts: 2,190
|
Re: Carb replacement
I have an 86 and after many cleanings and much reseting I came to the reluctant conclusion that a 25 + year old carburetor was never going to be at its prime so I bit the bullet and bought a new one. Now my cart runs like it just came off the production line. The correct model is the BV 18 and there are many available your target price is ~$100.
It is a good idea to remove the oil pump and premix the fuel. You must however ensure that the old oil pipe is sealed to prevent air being sucked into the manifold. I recommend that you cut the oil pipe about 1 inch from the carburetor elbow and drive a mastic covered screw into the pipe. If you want to you can tidy up by removing the pump, linkage and reservoir completely. You should now mix your fuel at 1 ounce oil to 1 gallon of fuel, which is 128:1. Yes I know it sounds dreadfully lean but trust me on this issue. You will hurt your engine if you run it much richer. As a final point it is not good to just throw the oil and gas into the gas tank. You should mix them in a separate container and shake vigorously to mix the solution before you pour it into the tank. Dave |
|
|
Similar Threads | ||||
Thread | Forum | |||
91 2 Cycle Carb Missing Carb Screw | Gas EZGO | |||
1980 Yamaha Carb replacement. | Gas Yamaha | |||
92 ds carb replacement | Gas Club Car | |||
G1 Carb Replacement | Gas Yamaha | |||
Carb Jet Replacement | Gas EZGO |