|
Gas Yamaha Gas Yamaha Golf Cars; G1 through "The Drive" and U-Max Utility Vehicles |
|
Thread Tools | Display Modes |
03-24-2014, 07:20 PM | #1 |
Not Yet Wild
Join Date: Aug 2011
Location: Sunshine state
Posts: 22
|
G2 needs choke to run
I have a g2 runs real good but needs the choke pulled about 1/4 of the way for it to run. If I pull the choke all the way out it bogs down, if I turn it off then I get only about 1/4 throttle and then it bogs. I have a new carb, new fuel pump, new lines, new plug, and filter. I would appreciate any ideas or experiences.
|
Today | |
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
03-24-2014, 07:30 PM | #2 |
Sometime's............
Join Date: Oct 2007
Location: Tacoma Washington
Posts: 11,874
|
Re: G2 needs choke to run
Try running it with the hose disconnected from the carb to the air box assy and see if it run's better. If so, airbox not sealed well.
|
03-24-2014, 07:37 PM | #3 |
Not Yet Wild
Join Date: Aug 2011
Location: Sunshine state
Posts: 22
|
Re: G2 needs choke to run
|
03-25-2014, 07:20 PM | #4 |
Not Yet Wild
Join Date: Aug 2011
Location: Sunshine state
Posts: 22
|
Re: G2 needs choke to run
So I tried disconnecting the intake tube. It ran good at idle but would not rev up with or without choke on, just bogged down. Anyone have another idea? Would also like to add that the foam prefilter is missing... would this cause a problem?
|
03-25-2014, 07:29 PM | #5 |
Gone Wild
Join Date: Oct 2010
Posts: 6,730
|
Re: G2 needs choke to run
Any backfiring going on?
|
03-25-2014, 07:37 PM | #6 |
Not Yet Wild
Join Date: Aug 2011
Location: Sunshine state
Posts: 22
|
Re: G2 needs choke to run
Yes if I try to run it with no choke or at full choke, it only likes 1/4.
|
03-25-2014, 07:40 PM | #7 |
Gone Wild
Join Date: Oct 2010
Posts: 6,730
|
Re: G2 needs choke to run
Have you checked valve lash?
Is the carb mounted securely with no air leaks? |
03-25-2014, 07:44 PM | #8 |
Not Yet Wild
Join Date: Aug 2011
Location: Sunshine state
Posts: 22
|
Re: G2 needs choke to run
The carb is good gasket was in great shape. I have not check the valves do you know where I can get the specs?
|
03-25-2014, 07:47 PM | #9 |
Gone Wild
Join Date: Oct 2010
Posts: 6,730
|
Re: G2 needs choke to run
Someone here can give the specs, but usually .004" - .008" is good. If it's backfiring because of the valve lash, it's usually because it is too tight.
Also, make sure the muffler isn't plugged, or the tailpiece crimped closed. |
03-25-2014, 08:00 PM | #10 |
Not Yet Wild
Join Date: Aug 2011
Location: Sunshine state
Posts: 22
|
Re: G2 needs choke to run
Thanks for the good info. I found specs in sticky .004 for both sides.
Do you think the muffler could be plugged even on a 4stroke? |
|
|
Similar Threads | ||||
Thread | Forum | |||
Choke has to be 1/2 way out to run.... | Gas Yamaha | |||
Choke me | Gas Club Car | |||
g1 and the choke | Gas Yamaha | |||
g1 choke | Gas Yamaha | |||
My G1 needs too much Choke | Gas Yamaha |