09-30-2020, 09:56 AM | #1 |
Not Yet Wild
Join Date: Nov 2019
Posts: 13
|
par car speed switch
hello all i have a 2009 par car 5fcle26a51000440 that came in after sitting a few years i replaced batteries then found a 4 flash code on the controller i removed the motor and found the armature badly arched and brushes scored. i then replaced the motor now we have movement but slow and hi low switch inop also no light on switch i only see 2 wire on the switch as normally a lighted switch should have 3 i did also swap out the speed sensor and magnet. please help thanks
|
Today | |
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
10-01-2020, 07:13 PM | #2 |
Not Yet Wild
Join Date: Sep 2020
Location: Redondo Beach, CA
Posts: 15
|
Re: par car speed switch
I am having similar issues. My speed switch never lit up when switching to rabbit.
I replaced my speed censor and magnet but still only going half speed. I don’t have any light flash but here is a link to the light flash guide I was able to find. https://cdn2.hubspot.net/hubfs/48320...-%20Sheet1.pdf |
10-01-2020, 07:33 PM | #3 |
How Can I Help?
Join Date: Oct 2009
Location: SW Wisc & West Central, FL
Posts: 1,385
|
Re: par car speed switch
Ignore the light on that rocker switch, was just a common switch and used without the light feature.
Have you checked that the accelerator is sending 100% signal to the controller? Older cables stretched and LAD’s moved a little so even though pedal is all the way to the floor the accelerator rod isnt fully pulling in the LAD. |
10-09-2020, 09:26 AM | #4 |
Not Yet Wild
Join Date: Nov 2019
Posts: 13
|
Re: par car speed switch
Yes tech i did the lad as soon as i loosened the u bolts the assembly rotated on its own but still no diference i do have the same speed in forward and reverse i already swaped out the magnet and sensor and tested the wires is it possible that the controller be burnt at that part i think the next step is send it to fsip for check out any more help before it goes out would be apprieciated
|
10-09-2020, 10:07 AM | #5 |
How Can I Help?
Join Date: Oct 2009
Location: SW Wisc & West Central, FL
Posts: 1,385
|
Re: par car speed switch
In over ten years I have never seen a controller fail the high/low circuit. Options in order of common failures are:
1. LAD adjustment 2. Accelerator cable 3. Speed encoder 4. High/low switch 5. Wiring issue between encoder and controller 6. 10k resistor 7. Controller programmed wrong |
10-12-2020, 07:16 AM | #6 |
Not Yet Wild
Join Date: Nov 2019
Posts: 13
|
Re: par car speed switch
i adjusted the cable and did make a difference i got 26 mph but it keeps cutting in and out it seems like if you feather the throttle it changes maybe lad itself im going to try to get a reading going thru the range
|
10-12-2020, 07:43 AM | #7 |
How Can I Help?
Join Date: Oct 2009
Location: SW Wisc & West Central, FL
Posts: 1,385
|
Re: par car speed switch
25 would be top lsv speed programming regardless of lad position so it should feel like its autocorrecting a bit.
|
10-12-2020, 08:01 AM | #8 |
Not Yet Wild
Join Date: Nov 2019
Posts: 13
|
Re: par car speed switch
it stops completely and its seems like if you cycle the key it works again and once it locked up a rear tire and other times it will only go about 13 mph i wish i had access to a reader but not much call in this area for par cars
|
10-12-2020, 08:22 AM | #9 |
How Can I Help?
Join Date: Oct 2009
Location: SW Wisc & West Central, FL
Posts: 1,385
|
Re: par car speed switch
When it stops dont cycle the key. Leave as is and count the flash sequence on the controller. It might help troubleshoot
|
10-12-2020, 10:56 AM | #10 |
Not Yet Wild
Join Date: Nov 2019
Posts: 13
|
Re: par car speed switch
Light stays on steady no flash i was hoeing to see the light flash (sorry about the caps my wife changes it all the time )
|
|
|
Similar Threads | ||||
Thread | Forum | |||
Speed switch | Electric EZGO | |||
Speed Switch / Pot Switch on BBB | Electric EZGO | |||
speed switch?!?!?! | Columbia ParCar | |||
two speed switch | Star and Fairplay |