|
Electric EZGO Electric EZ GO Marathon, Medalist, TXT and RXV. |
|
Thread Tools | Display Modes |
08-27-2014, 07:57 PM | #11 |
Gone Wild
Join Date: Aug 2014
Location: Duncan Corners
Posts: 905
|
Re: electric rxv won't move
Does cart roll with key off? if so BAD PARKING BRAKE
many RXV Wont Run / buzzer sounds problems are caused by bad parking brake. cart WILL NOT operate properly if parking brake fails power on test when key is turned "on" trojan 12v batteries give problems. low voltage causes brake lock up problems. would check parking brake and batteries before anything else. |
Today | |
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
08-27-2014, 08:07 PM | #12 |
Gone Wild
Join Date: Aug 2014
Location: Duncan Corners
Posts: 905
|
Re: electric rxv won't move
OZARK KING--
2009 cart with 2009 parking brake Well documented as failure prone. Would suspect brake is bad, if cart passes power on test (no Buzzer will try to accelerate /move when accelerator pushed) brake is bad. i have seen many bad (Locked up) brakes. NEVER seen bad RXV controller. bad old style 2008/9 solenoids. yes. 1 mph limp mode sounds like parking brake fail. |
11-07-2014, 07:48 PM | #13 |
Not Yet Wild
Join Date: May 2012
Posts: 4
|
Re: electric rxv won't move
I have a 2008 RXV, also with a 1 mph max speed. I was told by a shop that the encoder/bearing is suspect, especially if I had a old style brake lock-up in the past. I did have a lock-up so bad that the motor overheated brutally such that water sizzled fervently on the motor case. Amazingly though, once cooled and the brake problem fixed, we have run about two years with no problem. It makes sense as the encoder bearing is so close to the brake. Before I buy a bearing encoder $100, I'd like to know if anyone knows how to determine if an encoder is defective-maybe using an ohmeter.
Thanks D |
11-07-2014, 07:55 PM | #14 |
Gone Wild
Join Date: Aug 2014
Location: Duncan Corners
Posts: 905
|
Re: electric rxv won't move
Hi
Not easy to check anything (usefull) on RXV's with meter! dealer should use hand held scanner to check encoder-- motor command speed vs. actual speed should tell tale. |
11-08-2014, 04:50 AM | #15 |
Over This Interview Is...
Join Date: Jun 2012
Location: AZ
Posts: 17,449
|
Re: electric rxv won't move
|
11-08-2014, 08:14 AM | #16 |
Gone Wild
Join Date: Aug 2014
Location: Duncan Corners
Posts: 905
|
Re: electric rxv won't move
I rarely use DVM to troubleshoot RXV's
Mostly scan tool. (And i only get that out after checking parking/emergency brake) |
05-06-2020, 11:05 AM | #17 | |
Not Yet Wild
Join Date: May 2020
Posts: 5
|
Re: electric rxv won't move
Quote:
does that mean I need a new brake? just a girl with a little knowledge to be dangerous |
|
05-06-2020, 11:10 AM | #18 |
Not Yet Wild
Join Date: May 2020
Posts: 5
|
Re: electric rxv won't move
i have the rxv and I have the same problem. replaced solenoid, happened again. Now shop say its probably that I need a reducer because my radio and speakers are draining back battery. Not likely, batteries are two years old and other opinions say its not that.
Have you had any luck with trouble shooting? |
05-06-2020, 11:56 AM | #19 |
Gone Wild
Join Date: Jun 2016
Posts: 180
|
Re: electric rxv won't move
I had a similar problem with My 2009 RXV....nothing would move ..so I put The Tow/Run switch in TOW and key in N....tried to move the cart by hand...it was locked up...checked voltage at brake plug...OK next checked brake coil...27 ohms...again OK...plugged plug back into brake socket and was about to remove the brake thinking it was frozen...my arm brushed the plug wiring and I heard "Click"....found out the plug going into the brake was not making proper contact....On the course it failed again...wiggled the plug...cart went OK
|
05-06-2020, 07:45 PM | #20 | |
Resident Curmudgeon
Join Date: Oct 2011
Posts: 1,279
|
Re: electric rxv won't move
Quote:
|
|
|
|
Similar Threads | ||||
Thread | Forum | |||
ezgo electric will not move | Electric EZGO | |||
Club Car 25 Electric will not move | Electric Club Car | |||
89 electric par car wont move | Columbia ParCar | |||
95 48V Electric CC does not move in Fwd or Rev | Electric Club Car | |||
My electric ez-go quit and will not move | Electric EZGO |