|
Electric EZGO Electric EZ GO Marathon, Medalist, TXT and RXV. |
|
Thread Tools | Display Modes |
02-08-2016, 09:01 AM | #1 |
Not Yet Wild
Join Date: Jan 2016
Location: Mesa, AZ
Posts: 9
|
02 TXT PDS intermittant 3-2 code
So for a few years I've been chasing this same intermittent issue. I'll get a 3-2 code, but if I replace the solenoid, nothing changes. The symptom other than the code is the obvious reduction in speed. Pack voltage is 39.0 on year old Napa GC batteries. I run the troubleshooting flow chart from the service manual and get stopped at "Voltage between b- and controller side of solenoid... 0.4-0.8 Less than reference voltage?" It'll read reference voltage, not less than. About 2 years ago, I did replace the controller because of this result, but still have this intermittent issue. I will run great for months, then pop up again. I did clean the batteries Friday using a very light stream of water and battery cleaner, but there's no indication of moisture around the controller and the switch was set to "maint". I have the Freedom plug installed, but the problem consists with or without it installed. I can temporarily get the symptom to go away if I cycle the f-r switch and give accelerator input, but as soon as I shut the key off, it comes back. Last time this occurred, it remedied itself during troubleshooting. Thoughts? Thank you.
|
Today | |
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
02-08-2016, 09:17 AM | #2 |
Happy Carting
Join Date: Dec 2007
Location: Southern California
Posts: 73,418
|
Re: 02 TXT PDS intermittant 3-2 code
When you cycle the R/T switch you reboot the control. Since this clears the trouble code and the solenoid is not failing I suspect another controller failure.
|
02-08-2016, 09:23 AM | #3 |
Not Yet Wild
Join Date: Jan 2016
Location: Mesa, AZ
Posts: 9
|
Re: 02 TXT PDS intermittant 3-2 code
Is there an aftermarket controller that is better suited to daily higher speed operation? This is the superintendents cart and it's getting pretty old trying to explain a problem that comes and goes for no particular reason.
|
02-08-2016, 09:29 AM | #4 | |
Happy Carting
Join Date: Dec 2007
Location: Southern California
Posts: 73,418
|
Re: 02 TXT PDS intermittant 3-2 code
Quote:
|
|
02-08-2016, 12:43 PM | #5 |
Not Yet Wild
Join Date: Jan 2016
Location: Mesa, AZ
Posts: 9
|
Re: 02 TXT PDS intermittant 3-2 code
...and it started working as intended again. Ugh
Next failure, this thing is getting an Alltrax! |
02-08-2016, 01:00 PM | #6 |
Happy Carting
Join Date: Dec 2007
Location: Southern California
Posts: 73,418
|
Re: 02 TXT PDS intermittant 3-2 code
|
02-08-2016, 01:23 PM | #7 | |
Techno-Nerd
Join Date: Jun 2011
Location: West Virginia
Posts: 19,654
|
Re: 02 TXT PDS intermittant 3-2 code
Quote:
The small red wire that connects to the battery side large terminal on the solenoid, splits inside the wiring harness and feeds both the beeper and J1 Pin-5. The connection at the split goes bad sometimes and full pack voltage doesn't get to Pin-5. A bad connection at either end of the red wire will also do the same. However, being intermittent, I'm leaning towards a failing controller also. |
|
02-08-2016, 01:23 PM | #8 |
Not Yet Wild
Join Date: Jan 2016
Location: Mesa, AZ
Posts: 9
|
Re: 02 TXT PDS intermittant 3-2 code
Ha! Very good point. I'd still love to know what's going on when this happens. EZGO tech support didn't have much to offer. They told me inspect/clean the speed sensor. No change. Just kept messing with the FR and TM switches and viola!
|
02-08-2016, 01:45 PM | #9 |
Techno-Nerd
Join Date: Jun 2011
Location: West Virginia
Posts: 19,654
|
Re: 02 TXT PDS intermittant 3-2 code
golfcoursemonkey, I take it that you maintain carts at a golf course in the Phoenix area.
Are you familiar with the carts at Coyote Lake Golf Club or know any of the cart techs there? The reason I ask is because I bought a 2008PDS in 2011 that came off a 3 year lease and it has nose art that resembles the Coyote Lake Logo and was wondering if that is where it lived in its former life. |
02-10-2016, 08:32 AM | #10 | |
Not Yet Wild
Join Date: Jan 2016
Location: Mesa, AZ
Posts: 9
|
Re: 02 TXT PDS intermittant 3-2 code
Quote:
Coyote Lakes doesn't ring a bell. There are somewhere around 300 golf courses, so it's hard to keep track. Thanks for the input and advice on my issues, as well. I'm going to do some snooping around the harnesses, especially where they route behind the battery tray. See where I get. |
|
|
|
Similar Threads | ||||
Thread | Forum | |||
G-11 intermittant non-response | Gas Yamaha | |||
cart goes in rev,intermittant in fwd | Electric Club Car | |||
intermittant sputtering | Gas Club Car | |||
intermittant power | Electric Club Car | |||
Cart intermittant dead | Gas Club Car |