03-06-2021, 02:38 PM | #1 |
Not Yet Wild
Join Date: Mar 2021
Posts: 1
|
Club car gas radio cuts out
I installed a radio in 2008 club car gas last season, worked great. End of season started cutting out on acceleration. Replaced battery beginning this season, still cuts out. Disconnected everything except speakers, wires direct to battery, still cuts out? Any help appreciated. Thanks
|
Today | |
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
03-07-2021, 04:14 PM | #2 |
Resident Curmudgeon
Join Date: Oct 2011
Posts: 1,276
|
Re: Club car gas radio cuts out
Is the charging system even working? A gas cart should have 14.5+v at the battery when running. If radio is cutting out you're losing voltage when you shouldn't be.
|
03-07-2021, 05:15 PM | #3 |
Gone Wild
Join Date: Jun 2011
Location: Northern Indiana
Posts: 2,813
|
Re: Club car gas radio cuts out
On a related note: Too much voltage because of a failed voltage regulator will cause most modern radios to cut out - over voltage protection. Still check the voltage (rev up a bit, in maintenance mode of course). Too low or too high (over about 15.5) will cause problems.
|
03-07-2021, 11:31 PM | #4 |
Not Yet Wild
Join Date: Jul 2020
Posts: 20
|
Re: Club car gas radio cuts out
What type of spark plug do you have?
See if it has a resistor or not. |
03-23-2021, 11:48 AM | #5 |
Not Yet Wild
Join Date: Mar 2021
Location: Fl Panhandle
Posts: 11
|
Re: Club car gas radio cuts out
if you have a volt meter put it across radio battery leads and take it thru its paces, look for low or high voltage when it cuts out
|
03-23-2021, 03:07 PM | #6 |
Not Yet Wild
Join Date: Aug 2019
Posts: 40
|
Re: Club car gas radio cuts out
I will bet money on it being too high voltage. I chase that same problem around. Turned out to be a bad ground on the voltage regulator itself. I even replace the voltage regulator and starter generator trying to figure it out. But ultimately it was the voltage regulators ground.
Sent from my iPhone using Tapatalk |
|
Thread Tools | |
Display Modes | |
|
Similar Threads | ||||
Thread | Forum | |||
radio cuts out | Electric Club Car | |||
Radio cuts out when driving | Electric Club Car | |||
radio cuts off | Gas EZGO | |||
radio cuts out | Electric EZGO | |||
My Radio Cuts out | Gas Club Car |