|
08-16-2011, 02:43 PM
|
#1 |
|
Gone Wild
Join Date: Apr 2010
Location: West Tennessee
Posts: 1,269
|
Charger Question
I have a 2002 36 volt V-glide with resistor coils and new batteries. Runs great but when I plugged the so called good charger in it blew the fuse on the charger under the glass. So I tried another charger and blew the recepticle fuse on cart? Anyone know what may have happened? I have 37.5 volts across the pack, and looks to be wired right. The only wiring I am not sure about is the solenoid and charger receptacle, could be a crossed wire I am looking for problem as you read this post. There is a diode on the solenoid, not sure how to test it either. Is there a manual for 36 volt chargers?
 |
|
|
 Today
|
|
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
|
08-16-2011, 03:05 PM
|
#2 |
|
The Last Moja Morani
 Join Date: Jan 2007
Location: jumping from cart to cart
Posts: 8,975
|
Re: Charger Question
rich just sent you a reply to your PM check those 2 wires and double check how cables are run..............................
 |
|
|
|
|
08-16-2011, 03:15 PM
|
#3 |
|
Gone Wild
Join Date: Apr 2010
Location: West Tennessee
Posts: 1,269
|
Re: Charger Question
I have looked at both chargers and they are the same except for one wire inside, I have pics I can send via email if that would help? The cart looks to be word right +=hot and -=ground
Pic below shows the way it was wired, but I think that is wrong? the ground strap should not have a + wire to it right? |
|
|
|
|
08-16-2011, 04:45 PM
|
#4 |
|
The Last Moja Morani
Join Date: Jan 2007
Location: jumping from cart to cart
Posts: 8,975
|
Re: Charger Question
been so long since i opened a 36 volt charger i don,t know......sorry.........i,m trying to find a diagram for it.................................
|
|
|
|
|
08-16-2011, 04:48 PM
|
#5 |
|
Gone Wild
Join Date: Apr 2010
Location: West Tennessee
Posts: 1,269
|
Re: Charger Question
I tried to call Lester but they were already closed.
|
|
|
|
|
08-17-2011, 10:07 AM
|
#6 |
|
Gone Wild
Join Date: Apr 2010
Location: West Tennessee
Posts: 1,269
|
Re: Charger Question
Going to test the diode, says if the fuse only burns one side it could be a diode?
That's why I like gas carts!! |
|
|
|
|
08-17-2011, 05:23 PM
|
#7 |
|
Gone Wild
Join Date: Apr 2010
Location: West Tennessee
Posts: 1,269
|
Re: Charger Question
Replaced the diode board and fuse and good to go. It's amazing when you have enough info to troubleshoot what you can do.
 |
|
|
|
|
08-17-2011, 05:34 PM
|
#8 | |
|
......................
Join Date: Apr 2009
Location: FT Lauderdale FL.
Posts: 16,416
|
Re: Charger Question
Quote:
where did you find the info to fix it so others will know |
|
|
|
|
|
08-17-2011, 06:46 PM
|
#9 |
|
Gone Wild
Join Date: Apr 2010
Location: West Tennessee
Posts: 1,269
|
Re: Charger Question
|
|
|
|
 |
|
||||||
|
|
Similar Threads
|
||||
| Thread | Forum | |||
| 36v to 48v charger question | Electric EZGO | |||
| Charger Question | Electric Yamaha | |||
| Question for charger on 99 ez go | Electric EZGO | |||
| Charger Question | Electric EZGO | |||
| charger question | Electric Club Car | |||
Linear Mode
