|
Electric EZGO Electric EZ GO Marathon, Medalist, TXT and RXV. |
|
Thread Tools | Display Modes |
06-02-2014, 05:57 PM | #1 |
Getting Wild
Join Date: Dec 2011
Location: SE NC
Posts: 78
|
91 EZGO TXT won't go, solenoid not clicking.
went out the other day and our cart quit working.
I rolled it to the garage and checked all the connections, still no luck. It sat there a few days and my son jumped on it and it ran fine for a little while (30 minutes) then quit. I rolled it back outside my garage for a few days and let it sit. I then went back through making sure all the connections were clean, water levels filled etc and thought I had a loose switch. I tightened that up and the cart would go again. I pulled it into the garage to top off the charge and it wouldn't go. Usually when you switch the cart on, you can hear a distinct click of the solenoid engaging. When you lightly press the pedal, you can hear a lighter click of the pedal switch. I do not hear that initial solenoid click like I used to. I started reading through the diagnostic steps to check the solenoid this afternoon. I charged the pack on Saturday and went out there to check things out today. With my cheap analog meter, I get about 37.5 volts on the pack itself. If I switch the cart on in FWD, I get 37 on the battery side of the solenoid and 35 on the controller side of the solenoid. I even tried jumping the switch to make sure that was not the problem. I feel like something is not telling the solenoid to engage but according to the troubleshooting tips the solenoid isn't the problem. thanks in advance for your help. |
Today | |
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
06-02-2014, 06:50 PM | #2 |
Happy Carting
Join Date: Dec 2007
Location: Southern California
Posts: 73,419
|
Re: 91 EZGO TXT won't go, solenoid not clicking.
Before the solenoid gets the signal to engage, that signal goes through 3 other switches. Use the diagram below to trace it out starting at battery main.
|
06-02-2014, 08:20 PM | #3 |
Gone Wild
Join Date: Jan 2014
Location: South Georgia
Posts: 1,120
|
Re: 91 EZGO TXT won't go, solenoid not clicking.
I suggest you make some measurements on the solenoid to start with. The big terminals will have voltage on both if there is a resistor connected across them.. that is normal. The solenoid is not likely the problem
I am following scottyb's diagram. Just in case you have trouble reading diagrams the small terminals on the solenoid is what makes it click when one side gets B+ and the other side B-. If you get Battery B+ on the small terminal with the orange wire when you set the cart up to go and press the pedal that eliminates your two micro switches and the key switches being the problem. If not you going to have to start at the key switch and work your way through to see where you are missing voltage. On the diagram follow the red line through Key Switch, F-N-R micro switch MS-2 , MS-3 to the solenoid coil small terminal orange wire. The other side of the coil goes to B - on the black wire. Hope this helps. All voltage measured with voltmeter on Battery negative B- Be careful to protect against sudden cart movement when working on this. Best to put cart rear wheels on jack stands. Last edited by radioman; 06-02-2014 at 08:51 PM.. Reason: added safety note |
06-03-2014, 06:17 AM | #4 |
Getting Wild
Join Date: Dec 2011
Location: SE NC
Posts: 78
|
Re: 91 EZGO TXT won't go, solenoid not clicking.
thanks guys, Radioman I'm not too good at reading wiring diagrams so your description helps a lot. When I jump the orange wire I can hear the solenoid click. When I press the pedal the cart will go.
So if I follow things right this means either part of the FNR switch is bad or the microswitch is bad. Is there a way to check either of those switches? |
06-03-2014, 06:47 AM | #5 | |
Gone Wild
Join Date: Jan 2014
Location: South Georgia
Posts: 1,120
|
Re: 91 EZGO TXT won't go, solenoid not clicking.
Quote:
|
|
06-03-2014, 06:56 AM | #6 |
Getting Wild
Join Date: Dec 2011
Location: SE NC
Posts: 78
|
Re: 91 EZGO TXT won't go, solenoid not clicking.
ok, I hopped from the red wire on the micro switch to the orange wire and the solenoid did not engage. This leads me to believe part of the FNR switch is bad. Is that part replaceable or is it all one unit?
|
06-03-2014, 08:38 AM | #7 | |
Gone Wild
Join Date: Jan 2014
Location: South Georgia
Posts: 1,120
|
Re: 91 EZGO TXT won't go, solenoid not clicking.
Quote:
Please get a voltmeter. |
|
06-03-2014, 08:40 AM | #8 |
Master of All Things
Join Date: May 2013
Location: West Columbia, Texas
Posts: 18,001
|
Re: 91 EZGO TXT won't go, solenoid not clicking.
after all......they are CHEAP! you can get one at Wal-Mart for about $10 and will do most anything you will ever need it for.
Wal-mart......there are a few to choose from, as little as $8 http://www.walmart.com/search/search...h_constraint=0 |
06-03-2014, 09:06 AM | #9 |
Gone Wild
Join Date: Jan 2014
Location: South Georgia
Posts: 1,120
|
Re: 91 EZGO TXT won't go, solenoid not clicking.
Also it is not normal to hear the solenoid click when you turn the key on as you indicated in your original post. The solenoid should not click until you turn the key on and press the pedal. This indicates trouble in the pedal switch. The pedal micro switch should be open until you press the pedal. It is the last link to energizing the solenoid on the positive voltage side. When you get a voltmeter we can better help you. If you going to work on golf carts get one.
|
06-03-2014, 09:33 AM | #10 | |
Getting Wild
Join Date: Dec 2011
Location: SE NC
Posts: 78
|
Re: 91 EZGO TXT won't go, solenoid not clicking.
Quote:
I have a voltmeter, I'll use it going forward. I did another test... switch is on. F&R in F If I connect the neg to the B- and the pos of the meter to the red wire side of the micro switch that feeds from the F&R switch, I get 0 volts even when pressing the pedal. Wouldn't that mean that part of the the F&R switch is bad? I just remembered that I pulled the F&R switch off on Saturday day and noticed what looked similar to battery corrosion coming out of the one of the little boxes. This little box is the one that has the wire going to the micro switch. I'm assuming that is some kind of switch. I have attached a picture(borrowed from ebay) of the item I am talking about circled in red. |
|
|
|
Similar Threads | ||||
Thread | Forum | |||
solenoid not clicking | Electric EZGO | |||
98 EZGO TXT Clicking Solenoid | Electric EZGO | |||
1999 EZGO TXT Solenoid Not Clicking | Electric EZGO | |||
solenoid not clicking | Electric Club Car | |||
Clicking Solenoid | Electric EZGO |