|
10-03-2010, 08:34 PM
|
#1 |
|
Not Yet Wild
Join Date: May 2010
Location: WASHINGTON ST
Posts: 38
|
cart moves slow
I have a 81 ez-go and when you drive it does not want go but the engin is trying to go any one know why?
 |
|
|
 Today
|
|
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
|
10-03-2010, 10:42 PM
|
#2 |
|
Not Yet Wild
Join Date: May 2010
Location: WASHINGTON ST
Posts: 38
|
Re: cart moves slow
any one know how fix a clutch? I think it the problem
|
|
|
|
|
10-04-2010, 09:01 AM
|
#3 |
|
Gone Wild
Join Date: Aug 2010
Location: Pocono Mountains, PA
Posts: 162
|
Re: cart moves slow
How's the drive belt look?
Is it loose when sitting at idle or tight? Does it feel cupped on the top? Could be you just need to replace the drive belt but it's hard to tell from here! |
|
|
|
|
10-04-2010, 09:50 AM
|
#4 |
|
Hammer Down !!!!
Join Date: Jun 2010
Location: Lake Geneva, WI
Posts: 2,681
|
Re: cart moves slow
Here's a question that the answer may help us out locating your trouble, when you say it "wants to go" does it seem that the engine is straining against some unknown resistance or is the engine building RPM's just fine but no power is going to the drive system (like something is "slipping") ??
|
|
|
|
|
10-04-2010, 02:35 PM
|
#5 |
|
Not Yet Wild
Join Date: May 2010
Location: WASHINGTON ST
Posts: 38
|
Re: cart moves slow
the engine rpms are fine no power from the drive. The belt is new and tight. when the rear end is up off the ground the wheels have a hard time rotating in some spots and the clutch is making a loud sound when the gas is pushed.
|
|
|
|
|
10-04-2010, 03:56 PM
|
#6 |
|
Gone Wild
Join Date: Aug 2010
Location: Pocono Mountains, PA
Posts: 162
|
Re: cart moves slow
Sounds like you need to pull the rear wheels and drums off and check the brakes and bearings.
|
|
|
|
|
10-04-2010, 04:28 PM
|
#7 |
|
Not Yet Wild
Join Date: May 2010
Location: WASHINGTON ST
Posts: 38
|
Re: cart moves slow
thank you I will look at that. The clutch makes sounds any suggestions?
|
|
|
|
|
10-04-2010, 04:39 PM
|
#8 |
|
Gone Wild
Join Date: Aug 2010
Location: Pocono Mountains, PA
Posts: 162
|
Re: cart moves slow
Well.. if the wheels are bound up and the motor spins the clutch might just complain a little eh?
|
|
|
|
|
10-04-2010, 05:04 PM
|
#9 |
|
Not Yet Wild
Join Date: May 2010
Location: WASHINGTON ST
Posts: 38
|
Re: cart moves slow
with the wheel off the clutch still make the sound of a loose spring or something. the brakes and bearing look ok if I start the cart wth the wheels off the axle turns just fine and the clutch still makes the sound like a spring is loose.
|
|
|
|
|
10-04-2010, 05:13 PM
|
#10 |
|
Not Yet Wild
Join Date: May 2010
Location: WASHINGTON ST
Posts: 38
|
Re: cart moves slow
I looking for a parts manuals to see how the clutch works do u know where i can find one on a 81 thanks.
|
|
|
|
 |
|
||||||
| Thread Tools | |
| Display Modes | |
|
|
Similar Threads
|
||||
| Thread | Forum | |||
| '89 club car moves when key off??? | Electric Club Car | |||
| Cart moves slow then nothing | Electric Club Car | |||
| Forward Reverse switch arcs, cart moves with key off | Electric Club Car | |||
| Car moves, then dies... | Electric Club Car | |||
| Cart only moves at half throttle on 02 48 volt | Electric Club Car | |||
Linear Mode
