|
Gas Club Car Gas DS, and Precedent golf cars |
|
Thread Tools | Display Modes |
09-11-2018, 03:31 PM | #1 |
Not Yet Wild
Join Date: Sep 2018
Location: Alabama
Posts: 2
|
96 club car Will run only at half throttle
I have a 1996 Club Car gas. It only runs at halve throttle and then it is barely moving. I have cleaned carb put new plug in no change. It is getting gas and fire.When running it sounds like it is out of time. Flywheel key is not sheared'
|
Today | |
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
09-12-2018, 04:54 PM | #2 |
Not Yet Wild
Join Date: Oct 2016
Location: Cleveland Ohio
Posts: 13
|
Re: 96 club car Will run only at half throttle
A long long time ago I had a gocart that had a similar problem. Ended up being the plug wire was shot and shorting out against the head. Try running it in the dark and watch for it sparking.
Sent from my XT1254 using Tapatalk |
10-09-2018, 03:55 PM | #3 |
Not Yet Wild
Join Date: Sep 2018
Location: Alabama
Posts: 2
|
Re: 96 club car Will run only at half throttle
OK took a look at plug wire not shorting out in the dark, Checked valves not burnt still seating good and adjusted. But still will not rev up, carb has been cleaned and blown thru all ports No difference. If you take the drive belt off and disconnect the kill wire it will idle good. I connected my fire indicator and at idle it has a good fire but when you accelerate the fire is slower than at idle. I do not work on club carts a lot But I think my problem is in the fire. I know coils ether work or they do not and the same for igniters. Plug is black when you try to rev it up. Also has new plug Could it be the rev limiter.
|
10-10-2018, 03:22 PM | #4 |
Getting Wild
Join Date: Jul 2018
Location: Central Texas
Posts: 107
|
Re: 96 club car Will run only at half throttle
Coils do get tired over time. The higher the RPM, the more it works. Is the coil getting hot? It should not get hot. Can you swap in another coil to troubleshoot?
|
|
Thread Tools | |
Display Modes | |
|
Similar Threads | ||||
Thread | Forum | |||
Half throttle | Gas EZGO | |||
Only run at half throttle | Gas Yamaha | |||
yamaha g2 bogs at half throttle through full throttle | Gas Yamaha | |||
Half throttle only | Electric Yamaha | |||
Full throttle, Half throttle????? | Electric EZGO |