stuck pds motor

madoc1 · 10-07-2010, 08:04 PM

i looked, searched. whatever. could not find out why my pds motor would come off. final thindng to do was the 8# sledge. turns out on a pds, you need to remove a clip on the rear end and then pull the pds sensor out to reveale (sp) a machine screw and two washers. this motor was under water and trash anyway, but someone might have one that they could save. just info--wish i could have found this earleir . jim

gornoman · 10-07-2010, 11:10 PM

Not quite right. What you have done is removed the motor case and field coils, but left the armature behind. In essence, you have taken the motor apart, not removed it. The armature is still attached to the input shaft. At this point some heat from a propane torch may be needed to finish the job.

rib33024 · 10-07-2010, 11:29 PM

In the pic,- see #4 that bumper slides in side the shaft on the armature, that splined shaft slides on the input shaft of the rear end, that armature need to come off that shaft, like GORNOMAN said-

madoc1 · 10-08-2010, 06:35 AM

well that turned out to be the easy part. after soaking in pb overnight it came off without a struggle.

10-07-2010, 11:10 PM	#2
gornoman Stay thirsty my friends! Join Date: Jan 2007 Location: Suburban Chicago Posts: 24,290	Re: stuck pds motor Not quite right. What you have done is removed the motor case and field coils, but left the armature behind. In essence, you have taken the motor apart, not removed it. The armature is still attached to the input shaft. At this point some heat from a propane torch may be needed to finish the job.

10-07-2010, 11:29 PM	#3
rib33024 ...................... Join Date: Apr 2009 Location: FT Lauderdale FL. Posts: 16,416	Re: stuck pds motor In the pic,- see #4 that bumper slides in side the shaft on the armature, that splined shaft slides on the input shaft of the rear end, that armature need to come off that shaft, like GORNOMAN said-

Similar Threads
Thread	Forum
Stuck Electric Motor	Electric Club Car
Motor stuck on splines	Electric Club Car
Precedent motor stuck	Electric Club Car
Holy Stuck Motor Batman!!!	Electric Club Car
Stuck motor	Electric Club Car

Today
BGW	Sponsored Links __________________ This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum

10-08-2010, 06:35 AM	#4
madoc1 no clue Join Date: Sep 2009 Location: spicewood, texas Posts: 3,308	Re: stuck pds motor well that turned out to be the easy part. after soaking in pb overnight it came off without a struggle.