lifted club cars - lifted ezgo
Home FAQDonate Who's Online
Go Back   Buggies Gone Wild Golf Cart Forum > Golf Cart Repair and Troubleshooting > Gas Club Car
Gas Club Car Gas DS, and Precedent golf cars



Post New Thread  Reply
 
Thread Tools Display Modes
Old 09-29-2012, 12:35 PM   #1
02clubcards
Not Yet Wild
 
02clubcards's Avatar
Club Car
 
Join Date: Sep 2012
Location: NE Pennsylvania
Posts: 12
Default Cart won't shut off

Have a 2002 club car ds gas. When I step on gas pedal cart starts and runs but when I release gas pedal and turn key off and remove key the cart continues to run and move forward until I pull spark plug boot off to kill it.
Prior to this cart would not go. Would only idle so I replaced battery and coil. After I replaced coil the cart starts but the problem of not shutting off began.
Since then have replaced microswitches in electrical box and solenoid but still will not shut off.
Any ideas would be greatly appreciated.
02clubcards is offline   Reply With Quote
Alt Today
BGW

Golf car forum Sponsored Links

__________________
This advertising will not be shown in this way to registered members.
Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum
   
Old 10-03-2012, 07:46 PM   #2
02clubcards
Not Yet Wild
 
02clubcards's Avatar
Club Car
 
Join Date: Sep 2012
Location: NE Pennsylvania
Posts: 12
Default Re: Cart won't shut off

Also replaced voltage regulator which did not solve problem.
02clubcards is offline   Reply With Quote
Old 10-04-2012, 05:40 AM   #3
lockman1
What the ....?
 
lockman1's Avatar
Club Car
 
Join Date: Jan 2007
Location: N.E. Wisconsin
Posts: 14,900
Default Re: Cart won't shut off

Quote:
Originally Posted by 02clubcards View Post
After I replaced coil the cart starts but the problem of not shutting off began.
There should be a single wire coming from your coil, splits, and ties into the RPM limiter, then off to the electrical components box,
That's your "engine kill" circuit!

Something tells me that, that wire is disconnected either at the coil, (could happen while putting the engine shroud back on)
or at one of the two bullet connectors where it splits at the limiter!



lockman1 is offline   Reply With Quote
Old 10-04-2012, 11:57 AM   #4
02clubcards
Not Yet Wild
 
02clubcards's Avatar
Club Car
 
Join Date: Sep 2012
Location: NE Pennsylvania
Posts: 12
Default Re: Cart won't shut off

Thanks. Ill check these wires when I get chance and let you know. Don't think the one at coil is off because I checked it and tryed pulling it off before I put shroud on and wire would not come off coil. Ill check though.
02clubcards is offline   Reply With Quote
Reply
Go Back   Buggies Gone Wild Golf Cart Forum > Golf Cart Repair and Troubleshooting > Gas Club Car


Thread Tools
Display Modes


Similar Threads
Thread Forum
G16 won't shut off? Gas Yamaha
Cart diesels takes a minute to shut off Gas Club Car
Yamaha gas cart won't shut off Gas Yamaha
EZ GO ST 350 won't shut off Gas EZGO
Cart sped up then shut off Electric EZGO


All times are GMT -5. The time now is 02:45 PM.


Club Car Electric | EZGO Electric | Lifted Golf Carts | Gas EZGO | Used Golf Carts and Parts

Powered by vBulletin® Version 3.8.9
Copyright ©2000 - 2024, vBulletin Solutions, Inc.
This Website and forum is the property of Buggiesgonewild.com. No material may be taken or duplicated in part or full without prior written consent of the owners of buggiesgonewild.com. © 2006-2017 Buggiesgonewild.com. All rights reserved.