|
Electric Club Car Electric DS, and Precedent golf cars |
|
Thread Tools | Display Modes |
06-05-2019, 01:07 AM | #1 |
Not Yet Wild
Join Date: Oct 2017
Posts: 14
|
Club car / power drive charger
I have an older 2000 club car and a power drive charger.
Just purchased new batteries 6 months ago. Last weekend I noticed the battery level was down one bar. Didn’t pay much attention as I thought I just left it unplugged (it is normally constantly plugged in) Then this week I’m down 3-4 bars on the batter meter. Check the charger and the 15a breaker was tripped. Click it back in. Goes for 1-2 minutes trips again. Search google for the answer of how to fix it. Came up with replacing the heat sink and the breaker. Which I did. Plugged it back in and it seemed to be fixed. Charged for at least 39 minutes and I closed the garage door to go about my night and day. Came home tonight and the breaker is tripped once again. Pushed it in and it tripped after about 5 -7 minutes. Now I’m at a loss on what to do or try next. Any advice would be appreciated. Thanks, David |
Today | |
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
06-05-2019, 07:25 AM | #2 |
MOD of all BS!
Join Date: Sep 2011
Location: Florida
Posts: 17,477
|
Re: Club car / power drive charger
Read this https://www.revolutiongolfcars.com/t...roubleshooting and hopefully it is not your transformer and maybe a bad connection. Also, the heatsink has diodes and you need the correct ones. Not sure what the part number was on yours but if it was incorrect, it can cause problems too
You can call David at Revolution to verify the part numbers or needs. |
06-05-2019, 08:12 AM | #3 |
Gone Wild
Join Date: Sep 2012
Location: Charlotte, NC
Posts: 9,329
|
Re: Club car / power drive charger
Make sure also that the red wire from the charger receptacle is connected to the pack positive battery post or you will not charge the last battery.
|
06-05-2019, 11:00 AM | #4 |
Not Yet Wild
Join Date: Oct 2017
Posts: 14
|
Re: Club car / power drive charger
Thanks for the replies.
going through the trouble shooting guide now. I'm at work so I can't do any of it, but at least now I have some goals to get through when I get home. I'll double check all the wiring as well. However, nothing has changed as far as wiring or adding anything. All was working just fine for months and months. Then one day, poof. not charging, just tripping. I ordered a 1015914 off of Amazon. Looks the same as the one I took off. but I did not inspect the numbers at all. Hopefully I still have the old one. the one I ordered and installed: https://www.amazon.com/10L0L-Charger...gateway&sr=8-3 |
06-07-2019, 01:49 PM | #5 |
Not Yet Wild
Join Date: Oct 2017
Posts: 14
|
Re: Club car / power drive charger
Update:
started the troubleshooting guide that was posted on revolution golf carts. each battery tested at 8.2 total batteries tested at 49 checked the wiring. nothing broken. but quite a bid of corrosion. baking soda and water and a wire brush for some cleaning. tried to charge it, and the breaker tripped at 15 minutes. parked it in the garage and plugged it back in to see how long it would last the second time. waiting 10. still on. 15. still on. hour. still on. So I let it charge. I noticed after a couple hours it went from charging at 13amps to charging at 10amps. I left it alone and let it go overnight. Next day, battery meter on cart says fully charged. breaker was not tripped! So it seems like the trouble shooting guide worked for me. I plugged back in the charger just to see what would happen. And..... it only went to 10amps and then dropped to 3 amps, never doing the normal drop back down to 0 amps after a short time of initially plugging it in. I never seen this before, but then again I've never paid attention to this before either. Is that normal? should it be at 3amps for some reason? |
06-07-2019, 02:13 PM | #6 |
MOD of all BS!
Join Date: Sep 2011
Location: Florida
Posts: 17,477
|
Re: Club car / power drive charger
Gauges can be off, but it will never charge down to 0. It will drop to ~3-4 amps and perform the Finish or Topping off and then shut off. That last portion of the charge is when your voltage from the charger is at its highest; ~61-65vdc.
|
06-08-2019, 10:09 AM | #7 |
Not Yet Wild
Join Date: Oct 2017
Posts: 14
|
Re: Club car / power drive charger
ok thank you. Still new to this and know nothing about electricity.
It appears all is working then. Thank you for the help! |
|
|
Similar Threads | ||||
Thread | Forum | |||
48v Club Car Charger Power Drive | Golf Carts and Parts | |||
FS: 48v Club Car power drive charger | Golf Carts and Parts | |||
WANT TO BUY a Club Car Power Drive charger | Golf Carts and Parts | |||
Power Drive 3 Club Car Charger Help | Electric Club Car | |||
Club car power drive charger | Electric Club Car |