lifted club cars - lifted ezgo
Home FAQDonate Who's Online
Go Back   Buggies Gone Wild Golf Cart Forum > Golf Cart Repair and Troubleshooting > Electric EZGO
Electric EZGO Electric EZ GO Marathon, Medalist, TXT and RXV.



Post New Thread  Reply
 
Thread Tools Display Modes
Old 03-15-2012, 09:33 PM   #1
remyzero9987
Not Yet Wild
 
Join Date: Mar 2012
Posts: 4
Default Ezgo Txt Electric Problem

2007 Ezgo txt. I replaced all batteries after the cart would not move. I have good charge.I connected bl+ and bl- under control cover got 40.5 dc. Then did bl- with bolt on sylonoid closest to batteries got 41. Then did the otherside got 40. Then i did a jumper wire from bl+ to same bolt closest to batteries on syloniod and the cart responded by excellerating normally. Any idea what part to replace. Thank you in advance
remyzero9987 is offline   Reply With Quote
Alt Today
BGW

Golf car forum Sponsored Links

__________________
This advertising will not be shown in this way to registered members.
Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum
   
Old 03-15-2012, 09:43 PM   #2
scottyb
Happy Carting
 
scottyb's Avatar
E-Z-GO
 
Join Date: Dec 2007
Location: Southern California
Posts: 73,358
Default Re: Ezgo Txt Electric Problem

Your solenoid is not activating (no clicking noise)? You need to trace out the solenoid activation circuit... If the activation circuit is complete when you press the gas, then the solenoid may be bad... 9 times out of 10 it is in the activation circuit not the solenoid.


Is it a series or PDS cart?
scottyb is offline   Reply With Quote
Old 03-15-2012, 09:57 PM   #3
remyzero9987
Not Yet Wild
 
Join Date: Mar 2012
Posts: 4
Default Re: Ezgo Txt Electric Problem

its a pds. When i push the gas pedal i do hear a clicking noice but not out of the silinoid area the click comes from the pedal area like a spring noise. It seems like you know what my problem is, but i know very little about this stuff. Could you possibly specifically tell me what you would replace if it was you cart. Thanks
remyzero9987 is offline   Reply With Quote
Old 03-15-2012, 10:02 PM   #4
scottyb
Happy Carting
 
scottyb's Avatar
E-Z-GO
 
Join Date: Dec 2007
Location: Southern California
Posts: 73,358
Default Re: Ezgo Txt Electric Problem

Trouble shoot the solenoid activation circuit. that will tell where the problem is. Here is the circuit...

PDS solenoid activation
Power starts on the White wire on the 36+ of the battery pack.
Power travels to the charger receptacle, goes through a reed switch inside the receptacle and comes out on the red 12 gauge red wire.
The red wire travels back through the loom into controller molex connector at pin 4, out of pin9 to the keyswitch and back in pin 8, out pin 1 to the directional toggle switch & back in pin 3 or 4.
Finally coming out pin 7 to positive side of the solenoid activation circuit. (yellow)
The negative side of the solenoid activation circuit is out of pin #6 (blue)

The peddle micro switch is a separate control circuit at controller plug J4 basically red to switch and green back.
The Run/Tow switch is also a separate control circuit.
scottyb is offline   Reply With Quote
Old 03-15-2012, 10:37 PM   #5
remyzero9987
Not Yet Wild
 
Join Date: Mar 2012
Posts: 4
Default Re: Ezgo Txt Electric Problem

should i test for voltage between these points with voltage meter? Should they all be 36+. Also if i swicth from run to tow then back to run the car will jump when i push gas then die. it ran perfectly, then i took it apart to paint let the battieres ssit for two weeks and this happened
remyzero9987 is offline   Reply With Quote
Old 03-16-2012, 11:57 PM   #6
remyzero9987
Not Yet Wild
 
Join Date: Mar 2012
Posts: 4
Default Re: Ezgo Txt Electric Problem

Thank you for your help. After 20 hrs of staring at the electric and a wasted 1000 dollars later i discovered that below the tow run switch is another switch that was in the off position. You free help was greatly appreciated
remyzero9987 is offline   Reply With Quote
Reply
Go Back   Buggies Gone Wild Golf Cart Forum > Golf Cart Repair and Troubleshooting > Electric EZGO


Thread Tools
Display Modes


Similar Threads
Thread Forum
Electric EZGO speed problem...100% or nothing Electric EZGO
Ezgo Electric Problem Electric EZGO
04 ezgo electric problem Electric EZGO
2004 EZGO Electric Problem Electric EZGO
1992 ezgo(electric) problem Electric EZGO


All times are GMT -5. The time now is 07:48 PM.


Club Car Electric | EZGO Electric | Lifted Golf Carts | Gas EZGO | Used Golf Carts and Parts

Powered by vBulletin® Version 3.8.9
Copyright ©2000 - 2024, vBulletin Solutions, Inc.
This Website and forum is the property of Buggiesgonewild.com. No material may be taken or duplicated in part or full without prior written consent of the owners of buggiesgonewild.com. © 2006-2017 Buggiesgonewild.com. All rights reserved.