|
Electric Club Car Electric DS, and Precedent golf cars |
|
Thread Tools | Display Modes |
08-20-2018, 09:26 PM | #1 |
Gone Wild
Join Date: Feb 2015
Location: Quad cities
Posts: 334
|
Ds powerdrive battery light
I bought a cart from a junk pile payed 100 for it.cart was complete minus charge plug which i had one.I installed some used batterys took it for a ride.Drove great the light flashes on then off .Brought it back plugged the charger in wouldnt charge so i called it good for the night.Next mourning was going to delete the obc but before i did i plugged the charger in it started charging so i left it on it took a charge.Took it for another ride light flickering on then off.Plugged it back in called it good charged it took a charge unplugged it next day went for a ride the light was on then i turned the key switch on light went off,so i decided to try and reset the obc key off unhooked neg and positive cable put unit in reverse hold the throttle d own 5 minutes later buzzer still going off so i put it back together drove it around .light still flickers on the off is the light always powered with key off?The key switch was bad so i put a new one on it maybe wired it wrong any thought would be appreciated. I have a stand alone charger cart has been sitting dead with no batterys for years maybe more was suprized it still worked
|
Today | |
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
08-20-2018, 09:48 PM | #2 |
MOD of all BS!
Join Date: Sep 2011
Location: Florida
Posts: 17,477
|
Re: Ds powerdrive battery light
What is the year of the cart? And the OBC light will come on with the key on or off.... And if you still heard the buzzer, you did not have the correct cable off as after 5 minutes there would have been no power to energize it....)
|
08-20-2018, 10:04 PM | #3 |
Gone Wild
Join Date: Feb 2015
Location: Quad cities
Posts: 334
|
Re: Ds powerdrive battery light
1998 i took off postive cables and negative cables on the end of battery pack.when i was changing key switch the light would come on if i bumped the wires on the light maybe lightis bad?
|
08-20-2018, 10:08 PM | #4 |
MOD of all BS!
Join Date: Sep 2011
Location: Florida
Posts: 17,477
|
Re: Ds powerdrive battery light
If you had the pack disconnected, the OBC would be dead and unable to trigger the light. They key would be dead also....
|
08-21-2018, 05:11 AM | #5 |
Gone Wild
Join Date: Feb 2015
Location: Quad cities
Posts: 334
|
Re: Ds powerdrive battery light
The light came on after i put the key switch on and batteries connected when i was putting the dash back in maybe just a coinadent i will check it tonite again
|
08-21-2018, 12:24 PM | #6 |
MOD of all BS!
Join Date: Sep 2011
Location: Florida
Posts: 17,477
|
Re: Ds powerdrive battery light
I believe the light is working properly and at the start when it comes on it is telling you the batteries are already less than <90% charged. It comes on some as you ride to let you know you are reaching or at low charge levels for the pack. This is common with used batteries.
If you tried to plug it in immediately after a ride where the batteries got very low, the relay in the charger may not have had sufficient voltage to close in. After the batteries sat for a while and there static voltage came back up, it could have then closed in the relay and the charger came on.... Get a meter and check the pack voltage before, during, and after a ride. |
08-23-2018, 08:56 PM | #7 |
Gone Wild
Join Date: Feb 2015
Location: Quad cities
Posts: 334
|
Re: Ds powerdrive battery light
So far i think obc is a headache its been charging fine for two days rode the cart for a hour plugged it in no charge the light never blinked or came on tomorrow its getting yanked out including the i d iot light going with my old lestronic stand alone charger.Not sure if people like it i dont
|
08-23-2018, 10:41 PM | #8 |
Bonafide Nincompoop
Join Date: Dec 2015
Location: Charlottesburg Va
Posts: 8,987
|
Re: Ds powerdrive battery light
Used batteries + battery light + won't charge... Sounds like batteries are worn out and need to be replaced.
I have a fleet with 9 Electric Club cars, 6 of those are 1998 or older. All of them have an OBC. Haven't had a problem with the OBC on any of them, and they are far from perfect. When the battery light comes on, if it blinks, or stays on for a certain amount of time, it's a code for something. It can mean several different things. Get an owners manual for the cart and read about the OBC functions. It will explain exactly what the light means, and what it's trying to tell you. |
08-24-2018, 05:03 AM | #9 |
Gone Wild
Join Date: Feb 2015
Location: Quad cities
Posts: 334
|
Re: Ds powerdrive battery light
The light never came on i had these batteries in a nother cart using a stand alone charger never had a problem the batteries are ok i have load tested them used a hydrometer on them there fine.You need to remember this cart was in a junk yard dead for who knows how long maybe the obc was not working correctly to begine with just trying to figure it out the powerewise charger was also in the junk pile also left in the weather it could also be part of my problem.I have two differant stand alone chargers that work so thats the route im going.I was trying to keep it stock the cart didnt have any batteries in it when i brought it home not sure how the obc figures out how much to charge when it hasnt been used for so long with no batteries in it.
|
08-24-2018, 09:54 AM | #10 |
MOD of all BS!
Join Date: Sep 2011
Location: Florida
Posts: 17,477
|
Re: Ds powerdrive battery light
|
|
|
Similar Threads | ||||
Thread | Forum | |||
club car powerdrive battery charger model 17930 | Electric Club Car | |||
FS: 48v Club Car PowerDrive Battery Charger | Golf Carts and Parts | |||
98 Powerdrive 48 battery light on during charge | Electric Club Car | |||
96 CC powerdrive yellow battery light | Electric Club Car | |||
Club Car Powerdrive 2 Battery Charger Question | Electric Club Car |